Study of the Reflectivity of Silver Films Deposited by Radio Frequency and Direct Current Coupled Magnetron Sputtering
スポンサーリンク
概要
- 論文の詳細を見る
Silver films are deposited on a SiO2 surface and a cyclo-olefin polymer surface by radio frequency and direct current (RF--DC) coupled magnetron sputtering to realize light reflectors with high reflectivity in the visible light region. Because the reflectivity of silver is relatively low, especially in the short-wavelength region less than 500 nm owing to a slight increase in the refractive index of silver, deposition conditions are studied with emphasis on maximizing the reflectivity in this region. Also, protection film depositions of Si3N4 on a silver surface by microwave-excited-plasma-enhanced chemical vapor deposition were carried out to improve the durability of silver films, which are easily oxidized and/or sulfurized, resulting in the degradation of the reflectivity of the films. It is found that a high reflectivity in the short-wavelength region can be obtained by Xe plasma sputtering and/or Ar plasma sputtering at a relatively high working pressure, i.e., the conditions with a low ion bombardment energy at the substrate surface. At the same time, a normalized ion flux supplied to the substrate surface at approximately 2 is optimum, where the normalized ion flux is defined as the ratio of plasma-ion flux to deposited-atom flux on the growing film surface. Under such optimized deposition conditions, a silver film with a low resistivity and a smooth surface is obtained. Furthermore, it is found that a Si3N4 film with a thickness of 8 nm on a silver surface serves as a good protection film without serious degradation of reflectivity, and the reflectivity can be maintained even after the immersion of the sample in the boiling water (100 °C) for 2 h.
- 2011-01-25
著者
-
Goto Tetsuya
New Industry Creation Hatchery Center Tohoku University
-
Shirai Yasuyuki
New Industry Creation Hatchery Center (niche) Tohoku University
-
Ohmi Tadahiro
New Industry Creation Hatchery Center (niche) Tohoku University
-
Ohmi Tadahiro
New Industry Creation Hatchery Center, Tohoku University, Sendai 980-8579, Japan
-
Shirai Yasuyuki
New Industry Creation Hatchery Center, Tohoku University, Sendai 980-8579, Japan
-
Seki Nobuaki
New Industry Creation Hatchery Center, Tohoku University, Sendai 980-8579, Japan
関連論文
- High Current Drivability FD-SOI CMOS with Low Source/Drain Series Resistance(Session 9B : Nano-Scale devices and Physics)
- High Current Drivability FD-SOI CMOS with Low Source/Drain Series Resistance(Session 9B : Nano-Scale devices and Physics)
- Subvector-Based Fast Encoding Method for Vector Quantization Without Using Two Partial Variances
- Performance Comparison between Equal-Average Equal-Variance Equal-Norm Nearest Neighbor Search (EEENNS) Method and Improved Equal-Average Equal-Variance Nearest Neighbor Search (IEENNS) Method for Fast Encoding of Vector Quantization(Image Processing and
- Fast Encoding Method for Image Vector Quantization Based on Multiple Appropriate Features to Estimate Euclidean Distance
- A Fast Encoding Method for Vector Quantization Using Modified Memory-Efficient Sum Pyramid
- A Fast Search Method for Vector Quantization Using Enhanced Sum Pyramid Data Structure(Image)
- An Improved Fast Encoding Algorithm for Vector Quantization Using 2-Pixel-Merging Sum Pyramid and Manhattan-Distance-First Check(Image Processing, Image Pattern Recognition)
- A Fast Encoding Method for Vector Quantization Using L_1 and L_2 Norms to Narrow Necessary Search Scope(Image Processing, Image Pattern Recognition)
- A Fast Encoding Method for Vector Quantization Based on 2-Pixel-Merging Sum Pyramid Data Structure(Image)
- A nonlinear cepstral compensation method for noisy speech processing (音声言語情報処理 研究報告 第1回音声言語シンポジウム(SPLC))
- Extracting person's speech individually from original records of meeting by speaker identification technique
- Control of nitrogen profile in radical nitridation of SiO_2 films
- Tribological study for low shear force CMP process on damascene interconnects (シリコン材料・デバイス)
- Fully-Parallel VLSI Implementation of Vector Quantization Processor Using Neuron-MOS Technology (Special Issue on Integrated Electronics and New System Paradigms)
- Impact of fully depleted silicon-on-insulator accumulation-mode CMOS on Si(110) (シリコン材料・デバイス)
- Performance Comparison of Ultra-thin FD-SOI Inversion-, Intrinsic- and Accumulation-Mode MOSFETs
- Highly Reliable MOS Trench Gate FET by Oxygen Radical Oxidation
- Improved J-E Characteristics and Stress Induced Leakage Currents (SILC) in Oxynitride Films Grown at 400℃ by Microwave-Excited High-Density Kr/O_2/NH_3 Plasma
- Low Temperature Gate Oxidation MOS Transistor Produced by Kr/O_2 Microwave Excited High-Density Plasma
- Ultra-Thin Silicon Oxynitride Film Grown at Low-Temperature by Microwave-Excited High-Density Kr/O_2/N_2 Plasma
- Ultra-Thin Silicon Oxynitride Films as Cu Diffusion Barrier for Lowering Interconnect Resistivity
- High-Integrity Silicon Oxide Grown at Low-Temperature by Atomic Oxygen Generated in High-Density Krypton Plasma
- Low-Temperature Formation of Silicon Nitride Film by Direct Nitridation Employing High-Density and Low-Energy Ion Bombardment
- Effect of in-situ Formed Interlayer at Ta-SiO_2 interface on Performance and Reliability in Ta-Gate MOS Devices
- A Fine-Grained Programmable Logic Module with Small Amount of Configuration Data for Dynamically Reconfigurable Field-Programmable Gate Array
- Study on Compositional Transition Layers at Gate Dielectrics/Si Interface by using Angle-resolved X-ray Photoelectron Spectroscopy
- Study on Compositional Transition Layers at Gate Dielectrics/Si Interface by using Angle-resolved X-ray Photoelectron Spectroscopy
- Thin and Low-Resistivity Tantalum Nitride Diffusion Barrier and Giant-Grain Copper Interconnects for Advanced ULSI Metallization
- Thin and Low-Resistivity Tantalum Nitride Diffusion Barrier and Giant-Grain Copper Interconnects for Advanced ULSI Metallization
- Nitrogen Profile Study for SiON Gate Dielectrics of Advanced DRAM
- Data Analysis Technique of Atomic Force Microscopy for Atomically Flat Silicon Surfaces
- Low Contact Resistance with Low Schottky Barrier for N-type Silicon Using Yttrium Silicide
- Very Low Bit Error Rate in Flash Memory using Tunnel Dielectrics formed by Kr/O_2/NO Plasma Oxynitridation
- PVD Tantalum Oxide with Buffer Silicon Nitride Stacked High-k MIS Structure Using Low Temperature and High Density Plasma Processing
- Improved Transconductance and Gate Insulator Integrity of MISFETs with Si_3N_4 Gate Dielectric Fabricated by Microwave-Excited High-Density Plasma at 400℃
- Low Resistivity PVD TaNx/Ta/TaNx Stacked Metal Gate CMOS Technology Using Self-Grown bcc-Phased Tantalum on TaNx Buffer Layer
- A Statistical Analysis of Distributions of RTS Characteristics by Wide-Range Sampling Frequencies
- A Statistical Analysis of Distributions of RTS Characteristics by Wide-Range Sampling Frequencies
- A Material of Semiconductor Package with Low Dielectric Constant, Low Dielectric Loss and Flat Surface for High Frequency and Low Power Propagation(Session2: Silicon Devices I)
- A Material of Semiconductor Package with Low Dielectric Constant, Low Dielectric Loss and Flat Surface for High Frequency and Low Power Propagation(Session2: Silicon Devices I)
- The Evaluation of New Amorphous Hydrocarbon Film aCHx, for Copper Barrier Dielectric Film in Low-k Copper Metallization
- Low Dielectric Constant Non-Porous Fluorocarbon Films for Inter-Layer Dielectric
- A Large-Signal MOSFET Model Based on Transient Carrier Response for RF Circuits
- A High S/N Ratio Object Extraction CMOS Image Sensor with Column Parallel Signal Processing
- Analysis of High-Speed Signal Behavior in a Miniaturized Interconnect(Special Issue on Advanced Sub-0.1μm CMOS Devices)
- Interconnect and Substrate Structure for High Speed Giga-Scale Integration
- Characterization of Zinc Oxide Films Grown by a Newly Developed Plasma Enhanced MOCVD Employing Microwave Excited High Density Plasma
- Damage-Free Microwave-Excited Plasma Contact Hole Etching without Carrier Deactivation at the Interface between Silicide and Heavily-Doped Si
- Influence of Interface Structure on Oxidation Rate of Silicon : Surfaces, Interfaces, and Films
- High-Speed Damage-Free Contact Hole Etching Using Dual Shower Head Microwave-Excited High-Density-Plasma Equipment
- A Study on Reclaimed Photoresist Developer Using an Electrodialysis Method
- A Study on Reclaimed Photoresist Developer Using an Electrodialysis Method
- Ferroelectric Sr_2(Ta_, Nb_x)_2O_7 with a Low Dielectric Constant by Plasma Physical Vapor Deposition and Oxygen Radical Treatment
- Manufacturing Process of Flat Display(Micro Mechanical Engineering)
- Sonoluminescence measurement of 1MHz ultrasonic cavitation and effect of dissolved gases
- Ultrashallow and Low-Leakage p^+n Junction Formation by Plasma Immersion Ion Implantation (PIII) and Low-Temperature Post-Implantation Annealing
- Ultra-Shallow and Low-Leakage p^+n Junctions Formation by Plasma Immersion Ion Implantation (PIII) and Low-Temperature Post-Implantation Annealing
- A Dynamically Reconfigurable Processor with Multi-Mode Operation Based on Newly Developed Full-Adder/D-Flip-Flop Merged Module (FDMM)
- Impurity Measurement in Specialty Gases Using an Atmospheric Pressure Ionizaiton Mass Spectrometer with a Two-Compartment Ion Source
- Impurity Measurement in Specialty Gases Using Atmospheric Pressure Ionization Mass Spectrometer with Two Compartments Ion Source
- Tribological effects of brush scrubbing in post chemical mechanical planarization cleaning on electrical characteristics in novel non-porous low-k dielectric fluorocarbon on Cu interconnects (Special issue: Advanced metallization for ULSI applications)
- Electrical characteristics of novel non-porous low-k dielectric fluorocarbon on Cu interconnects for 22nm generation and beyond (Special issue: Advanced metallization for ULSI applications)
- A New Microwave-Excited Plasma Etching Equipment for Separating Plasma Excited Region from Etching Process Region
- A New Two-Step Round Oxidation STI Technology for Highly Reliable Flash Memory
- Study of the Metal-Ferroelectric-Insulator-Si Structure Device Formation by Controlling Properties of High Frequency and Microwave Excited Plasma
- MFIS-structure Memory Device with High Quality Ferroelectric Sr_2(Ta_Nb_x)_2O_7 Formed by Physical Vapor Deposition and Oxygen Radical Treatment by Radical Oxygen Assisted Layer by Layer(ROALL) deposition
- Adsorption Behavior of Various Fluorocarbon Gases on Silicon Wafer Surface
- A Low-Dielectric-Constant Sr_2(Ta_, Nb_x)_2O_7 Thin Film Controlling the Crystal Orientation on an IrO_2 Substrate for One-Transistor-Type Ferroelectric Memory Device
- Study of the Reflectivity of Silver Films Deposited by Radio Frequency and Direct Current Coupled Magnetron Sputtering
- Analysis of the Low-Frequency Noise Reduction in Si(100) Metal--Oxide--Semiconductor Field-Effect Transistors
- A 100 MHz 7.84 mm^2 31.7 msec 439 mW 512-Point 2-Dimensional FFT Single-Chip Processor(Low-Power System LSI, IP and Related Technologies)
- Impact of Channel Direction Dependent Low Field Hole Mobility on (100) Orientation Silicon Surface
- Suppression of the low frequency noise level in (100) and (110) oriented silicon p-MOSFETs induced by an alkali-free cleaning process
- High-Rate Deposition of Amorphous Silicon Films by Microwave-Excited High-Density Plasma
- Eliminating Needless Calculations on Circuit Level : Most-Significant-Digit-First Digit-Serial Processing
- Fast Computational Architectures to Decrease Redundant Calculations : Eliminating Redundant Digit Calculation and Excluding Useless Data (Special Issue on Integrated Electronics and New System Paradigms)
- The Effect of Organic Contaminations Molecular Weights in the Cleanroom Air on MOS Devices Degradation - a Controlled laminar Air Flow Experiment
- The Effect of Organic Compounds Contamination on the Electrical Characteristics of Ultra-Thin Gate Oxide Films
- Technology of Ferroelectric Thin Film Formation with Large Coercive Field for Future Scaling Down of Ferroelectric Gate FET Memory Device
- A New Statistical Evaluation Method for the Variation of MOSFETs
- Low Leakage Current and Low Resistivity p^+n Diodes on Si(110) Fabricated by Ga^+/B^+ Combination I/I and Low Temperature Annealing
- Electrical Properties of Metal-Oxide-Containing SiO2 Films Formed by Organosiloxane Sol–Gel Precursor
- Formation of Ferroelectric Sr_2(Ta_,Nb_x)_2O_7 Thin Film on Amorphous SiO_2 by Microwave-Excited Plasma Enhanced Metalorganic Chemical Vapor Deposition
- Impact of The Improved High Performance Si(110) Oriented MOSFETs by Using Accumulation-Mode Fully Depleted SOI Devices
- A Comparative Examination of Polyoxide Films Performance Grown by Conventional Dry Thermal (900℃) or Plasma Assisted (400℃) Oxidation Techniques
- Perfectly Etching Uniformity Control of Various Doped Oxide Films Using an Anhydrous HF Gas
- Fast Gas Replacement in Plasma Process Chamber by Improving Gas Flow Pattern
- A New Microwave-Excited Plasma Etching Equipment for Separating Plasma Excited Region from Etching Process Region
- Gas Flow Characteristics in a Plasma Process Chamber and Proposal of New Pulse-Controlled Gas Injection Method Using Interference Matrix Operation for Rapid Stabilization of Gas Pressure
- Deposition of Microcrystalline Si1-xGex by RF Magnetron Sputtering on SiO2 Substrates
- Impact of Tungsten Capping Layer on Yttrium Silicide for Low-Resistance n+-Source/Drain Contacts
- Low Contact Resistivity with Low Silicide/p+-Silicon Schottky Barrier for High-Performance p-Channel Metal–Oxide–Silicon Field Effect Transistors
- Ferroelectric Sr2(Ta1-x, Nbx)2O7 with a Low Dielectric Constant by Plasma Physical Vapor Deposition and Oxygen Radical Treatment
- A Low-Dielectric-Constant Sr2(Ta1-x,Nbx)2O7 Thin Film Controlling the Crystal Orientation on an IrO2 Substrate for One-Transistor-Type Ferroelectric Memory Device
- Development of Microwave-Excited Plasma-Enhanced Metal–Organic Chemical Vapor Deposition System for Forming Ferroelectric Sr2(Ta1-x,Nbx)2O7 Thin Film on Amorphous SiO2
- High-Speed Damage-Free Contact Hole Etching Using Dual Shower Head Microwave-Excited High-Density-Plasma Equipment
- Impact of the Use of Xe on Electrical Properties in Magnetron-Sputtering Deposited Amorphous InGaZnO Thin-Film Transistors
- Formation and Property of Yttrium and Yttrium Silicide Films as Low Schottcky Barrier material for n-Type Silicon
- Adhesion Characteristics of Magnetron-Sputter-Deposited Copper on Smooth Cycloolefin for Realizing Wiring with High-Frequency Signal Propagation