In situ Observation of Grain Growth on Electroplated Cu Film by Electron Backscatter Diffraction

スポンサーリンク

概要

• 論文の詳細を見る

• In situ observations using an automated electron backscatter diffraction (EBSD) system with a heating stage were carried out to clarify the mechanism of grain growth on electroplated Cu and Cu deposited by physical vapor deposition (PVD). Hardness measurements and EBSD observations revealed that the strain in electroplated Cu and Cu deposited by PVD was released by annealing. Little preferential orientation of the texture was observed in electroplated Cu, while Cu deposited by PVD showed strong (111) texture. A greater number of twin boundaries were observed in electroplated Cu than in Cu deposited by PVD. Grains surrounded by random grain boundaries were more enlarged by annealing in electroplated Cu than those in Cu deposited by PVD. Since segregation of impurities with a low melting point, such as sulfur, to grain boundaries could promote grain growth, which is often accompanied by twin boundary formation, the reason that many twin boundaries are found in electroplated Cu is considered to be the existence of impurities such as sulfur at grain boundaries. The effect of a twin grain boundary on resistivity was calculated and the contribution of a twin grain boundary to resistivity was found to be much less than that of a random grain boundary.

• 2009-06-25

著者

• Tsurekawa Sadahiro

  Laboratory Of Materials Design And Interface Engineering Department Of Nanomechanics Graduate School

• Ohmi Tadahiro

  New Industry Creation Hatchery Center (niche) Tohoku University

• Teramoto Akinobu

  New Industry Creation Hatchery Center (NICHe), Tohoku University, Sendai 980-8579, Japan

• Nemoto Takenao

  New Industry Creation Hatchery Center (NICHe), Tohoku University, Sendai 980-8579, Japan

• Fukino Tatsuya

  Laboratory of Material Design for Solar Energy and Interface Engineering, Faculty of Engineering, Kumamoto University, Kumamoto 860-8555, Japan

• Gu Xun

  Graduate School of Engineering, Tohoku University, Sendai 980-8579, Japan

• Tsurekawa Sadahiro

  Laboratory of Material Design for Solar Energy and Interface Engineering, Faculty of Engineering, Kumamoto University, Kumamoto 860-8555, Japan

• Gu Xun

  Graduate School of Engineering, Tohoku University

関連論文

• High Current Drivability FD-SOI CMOS with Low Source/Drain Series Resistance(Session 9B : Nano-Scale devices and Physics)
• High Current Drivability FD-SOI CMOS with Low Source/Drain Series Resistance(Session 9B : Nano-Scale devices and Physics)
• Subvector-Based Fast Encoding Method for Vector Quantization Without Using Two Partial Variances
• Performance Comparison between Equal-Average Equal-Variance Equal-Norm Nearest Neighbor Search (EEENNS) Method and Improved Equal-Average Equal-Variance Nearest Neighbor Search (IEENNS) Method for Fast Encoding of Vector Quantization(Image Processing and
• Fast Encoding Method for Image Vector Quantization Based on Multiple Appropriate Features to Estimate Euclidean Distance
• A Fast Encoding Method for Vector Quantization Using Modified Memory-Efficient Sum Pyramid
• A Fast Search Method for Vector Quantization Using Enhanced Sum Pyramid Data Structure(Image)
• An Improved Fast Encoding Algorithm for Vector Quantization Using 2-Pixel-Merging Sum Pyramid and Manhattan-Distance-First Check(Image Processing, Image Pattern Recognition)
• A Fast Encoding Method for Vector Quantization Using L_1 and L_2 Norms to Narrow Necessary Search Scope(Image Processing, Image Pattern Recognition)
• A Fast Encoding Method for Vector Quantization Based on 2-Pixel-Merging Sum Pyramid Data Structure(Image)
• A nonlinear cepstral compensation method for noisy speech processing (音声言語情報処理 研究報告 第1回音声言語シンポジウム(SPLC))
• Extracting person's speech individually from original records of meeting by speaker identification technique
• Control of nitrogen profile in radical nitridation of SiO_2 films
• Tribological study for low shear force CMP process on damascene interconnects (シリコン材料・デバイス)
• Fully-Parallel VLSI Implementation of Vector Quantization Processor Using Neuron-MOS Technology (Special Issue on Integrated Electronics and New System Paradigms)
• Impact of fully depleted silicon-on-insulator accumulation-mode CMOS on Si(110) (シリコン材料・デバイス)
• Performance Comparison of Ultra-thin FD-SOI Inversion-, Intrinsic- and Accumulation-Mode MOSFETs
• Highly Reliable MOS Trench Gate FET by Oxygen Radical Oxidation
• Improved J-E Characteristics and Stress Induced Leakage Currents (SILC) in Oxynitride Films Grown at 400℃ by Microwave-Excited High-Density Kr/O_2/NH_3 Plasma
• Low Temperature Gate Oxidation MOS Transistor Produced by Kr/O_2 Microwave Excited High-Density Plasma
• Ultra-Thin Silicon Oxynitride Film Grown at Low-Temperature by Microwave-Excited High-Density Kr/O_2/N_2 Plasma
• Ultra-Thin Silicon Oxynitride Films as Cu Diffusion Barrier for Lowering Interconnect Resistivity
• High-Integrity Silicon Oxide Grown at Low-Temperature by Atomic Oxygen Generated in High-Density Krypton Plasma
• Low-Temperature Formation of Silicon Nitride Film by Direct Nitridation Employing High-Density and Low-Energy Ion Bombardment
• Effect of in-situ Formed Interlayer at Ta-SiO_2 interface on Performance and Reliability in Ta-Gate MOS Devices
• A Fine-Grained Programmable Logic Module with Small Amount of Configuration Data for Dynamically Reconfigurable Field-Programmable Gate Array
• Study on Compositional Transition Layers at Gate Dielectrics/Si Interface by using Angle-resolved X-ray Photoelectron Spectroscopy
• Study on Compositional Transition Layers at Gate Dielectrics/Si Interface by using Angle-resolved X-ray Photoelectron Spectroscopy
• High Temperature In-situ Observations of Magnetic Domains in Fe-Co Alloys
• Grain Boundary Microstructure-Controlled Superplasticity in Al-Li-Cu-Mg-Zr Alloy
• Thin and Low-Resistivity Tantalum Nitride Diffusion Barrier and Giant-Grain Copper Interconnects for Advanced ULSI Metallization
• Thin and Low-Resistivity Tantalum Nitride Diffusion Barrier and Giant-Grain Copper Interconnects for Advanced ULSI Metallization
• Nitrogen Profile Study for SiON Gate Dielectrics of Advanced DRAM
• Data Analysis Technique of Atomic Force Microscopy for Atomically Flat Silicon Surfaces
• Low Contact Resistance with Low Schottky Barrier for N-type Silicon Using Yttrium Silicide
• Very Low Bit Error Rate in Flash Memory using Tunnel Dielectrics formed by Kr/O_2/NO Plasma Oxynitridation
• PVD Tantalum Oxide with Buffer Silicon Nitride Stacked High-k MIS Structure Using Low Temperature and High Density Plasma Processing
• Improved Transconductance and Gate Insulator Integrity of MISFETs with Si_3N_4 Gate Dielectric Fabricated by Microwave-Excited High-Density Plasma at 400℃
• Low Resistivity PVD TaNx/Ta/TaNx Stacked Metal Gate CMOS Technology Using Self-Grown bcc-Phased Tantalum on TaNx Buffer Layer
• A Statistical Analysis of Distributions of RTS Characteristics by Wide-Range Sampling Frequencies
• A Statistical Analysis of Distributions of RTS Characteristics by Wide-Range Sampling Frequencies
• A Material of Semiconductor Package with Low Dielectric Constant, Low Dielectric Loss and Flat Surface for High Frequency and Low Power Propagation(Session2: Silicon Devices I)
• A Material of Semiconductor Package with Low Dielectric Constant, Low Dielectric Loss and Flat Surface for High Frequency and Low Power Propagation(Session2: Silicon Devices I)
• The Evaluation of New Amorphous Hydrocarbon Film aCHx, for Copper Barrier Dielectric Film in Low-k Copper Metallization
• Low Dielectric Constant Non-Porous Fluorocarbon Films for Inter-Layer Dielectric
• A Large-Signal MOSFET Model Based on Transient Carrier Response for RF Circuits
• A High S/N Ratio Object Extraction CMOS Image Sensor with Column Parallel Signal Processing
• Analysis of High-Speed Signal Behavior in a Miniaturized Interconnect(Special Issue on Advanced Sub-0.1μm CMOS Devices)
• Interconnect and Substrate Structure for High Speed Giga-Scale Integration
• Characterization of Zinc Oxide Films Grown by a Newly Developed Plasma Enhanced MOCVD Employing Microwave Excited High Density Plasma
• Damage-Free Microwave-Excited Plasma Contact Hole Etching without Carrier Deactivation at the Interface between Silicide and Heavily-Doped Si
• Influence of Interface Structure on Oxidation Rate of Silicon : Surfaces, Interfaces, and Films
• A Study on Reclaimed Photoresist Developer Using an Electrodialysis Method
• A Study on Reclaimed Photoresist Developer Using an Electrodialysis Method
• Manufacturing Process of Flat Display(Micro Mechanical Engineering)
• Sonoluminescence measurement of 1MHz ultrasonic cavitation and effect of dissolved gases
• Ultrashallow and Low-Leakage p^+n Junction Formation by Plasma Immersion Ion Implantation (PIII) and Low-Temperature Post-Implantation Annealing
• Ultra-Shallow and Low-Leakage p^+n Junctions Formation by Plasma Immersion Ion Implantation (PIII) and Low-Temperature Post-Implantation Annealing
• A Dynamically Reconfigurable Processor with Multi-Mode Operation Based on Newly Developed Full-Adder/D-Flip-Flop Merged Module (FDMM)
• Impurity Measurement in Specialty Gases Using an Atmospheric Pressure Ionizaiton Mass Spectrometer with a Two-Compartment Ion Source
• Impurity Measurement in Specialty Gases Using Atmospheric Pressure Ionization Mass Spectrometer with Two Compartments Ion Source
• Tribological effects of brush scrubbing in post chemical mechanical planarization cleaning on electrical characteristics in novel non-porous low-k dielectric fluorocarbon on Cu interconnects (Special issue: Advanced metallization for ULSI applications)
• Electrical characteristics of novel non-porous low-k dielectric fluorocarbon on Cu interconnects for 22nm generation and beyond (Special issue: Advanced metallization for ULSI applications)
• Magnetic Sintering of Ferromagnetic Metal Powder Compacts
• A New Two-Step Round Oxidation STI Technology for Highly Reliable Flash Memory
• Study of the Metal-Ferroelectric-Insulator-Si Structure Device Formation by Controlling Properties of High Frequency and Microwave Excited Plasma
• MFIS-structure Memory Device with High Quality Ferroelectric Sr_2(Ta_Nb_x)_2O_7 Formed by Physical Vapor Deposition and Oxygen Radical Treatment by Radical Oxygen Assisted Layer by Layer(ROALL) deposition
• Study of the Reflectivity of Silver Films Deposited by Radio Frequency and Direct Current Coupled Magnetron Sputtering
• Analysis of the Low-Frequency Noise Reduction in Si(100) Metal--Oxide--Semiconductor Field-Effect Transistors
• A 100 MHz 7.84 mm^2 31.7 msec 439 mW 512-Point 2-Dimensional FFT Single-Chip Processor(Low-Power System LSI, IP and Related Technologies)
• Impact of Channel Direction Dependent Low Field Hole Mobility on (100) Orientation Silicon Surface
• Suppression of the low frequency noise level in (100) and (110) oriented silicon p-MOSFETs induced by an alkali-free cleaning process
• High-Rate Deposition of Amorphous Silicon Films by Microwave-Excited High-Density Plasma
• Eliminating Needless Calculations on Circuit Level : Most-Significant-Digit-First Digit-Serial Processing
• Fast Computational Architectures to Decrease Redundant Calculations : Eliminating Redundant Digit Calculation and Excluding Useless Data (Special Issue on Integrated Electronics and New System Paradigms)
• The Effect of Organic Contaminations Molecular Weights in the Cleanroom Air on MOS Devices Degradation - a Controlled laminar Air Flow Experiment
• The Effect of Organic Compounds Contamination on the Electrical Characteristics of Ultra-Thin Gate Oxide Films
• Technology of Ferroelectric Thin Film Formation with Large Coercive Field for Future Scaling Down of Ferroelectric Gate FET Memory Device
• A New Statistical Evaluation Method for the Variation of MOSFETs
• Low Leakage Current and Low Resistivity p^+n Diodes on Si(110) Fabricated by Ga^+/B^+ Combination I/I and Low Temperature Annealing
• Electrical Properties of Metal-Oxide-Containing SiO2 Films Formed by Organosiloxane Sol–Gel Precursor
• Formation of Ferroelectric Sr_2(Ta_,Nb_x)_2O_7 Thin Film on Amorphous SiO_2 by Microwave-Excited Plasma Enhanced Metalorganic Chemical Vapor Deposition
• Impact of The Improved High Performance Si(110) Oriented MOSFETs by Using Accumulation-Mode Fully Depleted SOI Devices
• A Comparative Examination of Polyoxide Films Performance Grown by Conventional Dry Thermal (900℃) or Plasma Assisted (400℃) Oxidation Techniques
• Impact of High Performance Accumulation-Mode Fully Depleted SOI MOSFETs (先端デバイスの基礎と応用に関するアジアワークショップ(AWAD2005))
• Impact of High Performance Accumulation-Mode Fully Depleted SOI MOSFETs (先端デバイスの基礎と応用に関するアジアワークショップ(AWAD2005))
• Precise Control of Gas Concentration Ratio in Process Chamber : Instrumentation, Measurement, and Fabrication Technology
• Source/Drain Dopant Deactivation and Junction Degradation by Energetic Ions in Plasma Processes
• Improvement of Oxidation Resistance and Oxidation-Induced Embrittlement by Controlling Grain Boundary Microstructure in Silicon Carbides with Different Dopants
• Dopant-Induced Defects Formed by Ion Implantation : Dopant Species Dependence
• Highly reliable radical SiO2 films on atomically flat silicon surface formed by low temperature pure Ar annealing (Special issue: Dielectric thin films for future electron devices: science and technology)
• Perfectly Etching Uniformity Control of Various Doped Oxide Films Using an Anhydrous HF Gas
• Large-scale test circuits for high-speed and highly accurate evaluation of variability and noise in metal-oxide-semiconductor field-effect transistor electrical characteristics
• In situ Observation of Grain Growth on Electroplated Cu Film by Electron Backscatter Diffraction
• Nitrogen Profile Study for SiON Gate Dielectrics of Advanced Dynamic Random Access Memory
• The Control of Oxidation-Induced Intergranular Embrittlement by Grain Boundary Engineering in Rapidly Solidified Ni-Fe Alloy Ribbons
• A12-081 MANUFACTURING PROCESS OF FLAT DISPLAY
• Anomalous Random Telegraph Signal Extractions from a Very Large Number of n-Metal Oxide Semiconductor Field-Effect Transistors Using Test Element Groups with 0.47 Hz–3.0 MHz Sampling Frequency
• Depth Profile of Nitrogen Atoms in Silicon Oxynitride Films Formed by Low-Electron-Temperature Microwave Plasma Nitridation
• Fast Gas Replacement in Plasma Process Chamber by Improving Gas Flow Pattern

もっと見る 閉じる

スポンサーリンク