Wafer Cleaning with Photoexcited Chlorine and Thermal Treatment for High-Quality Silicon Epitaxy
スポンサーリンク
概要
- 論文の詳細を見る
The authors propose a new photoexcited silicon-wafer cleaning technique, in which ultraviolet light irradiates the wafer through chlorine gas, followed by thermal treatment in a hydrogen ambient, to grow a high-quality epitaxial layer. The surface metal contaminants were removed through a thin native oxide without damaging the surface by photoexcited cleaning, and the remaining volatile chloride after the photoexcited cleaning at 150°C was removed by thermal treatment at 900°C. Further thermal treatment at 980°C removed even the thin native oxide and then made it possible to grow an epitaxial silicon layer. The SiO2 film formed using a conventional technique on the epitaxial silicon layer showed improved breakdown fields and a decrease of fixed-charge density. The results mean that a high-quality silicon-epitaxial layer has been realized by the cleaning procedure.
- INSTITUTE OF PURE AND APPLIED PHYSICSの論文
- 1989-10-20
著者
-
ITO Takashi
Fujitsu Laboratories Ltd.
-
Nara Yasuo
Fujitsu Laboratories Ltd.
-
SUGINO Rinshi
Fujitsu Laboratories Lid.
-
Yamazaki Tatsuya
FUJITSU LABORATORIES LTD.
-
Watanabe Satoru
Fujita Health University
-
Yamazaki Tatsuya
FUJITSU LABORATORIES LTD., 10-1 Morinosato-Wakamiya, Atsugi 243-01
-
Sugino Rinshi
FUJITSU LABORATORIES LTD., 10-1 Morinosato-Wakamiya, Atsugi 243-01
関連論文
- X-Ray Reflectometry and Infrared Analysis of Native Oxides on Si (100) Formed by Chemical Treatment
- Transient Oxide Layer at a Thermally Grown SiO_2/Si Interface, Interpreted Based on Local Vibration and X-Ray Reflectivity
- X-Ray Reflectometry and Infrared Analysis of Native Oxides on Si(100) Formed in Chemical Treatment
- Silicon-Hydrogen Bonds in Silicon Native Oxides Formed during Wet Chemical Treatments
- Fabrication and Delay Time Analysis of Deep Submicron CMOS Devices
- Ti Salicide Process for Subquarter-Micron CMOS Devices (Special Issue on Quarter Micron Si Device and Process Technologies)
- Wafer Cleaning with Photoexcited Chlorine and Thermal Treatment for High-Quality silicon Epitaxy : Beam Induced Physics and Chemistry
- Advanced SOI Devices Using CMP and Wafer Bonding
- Coulomb Interaction Effect Correction in Electron-Beam Block Exposure Lithography
- Quantum-Size Effect from Photoluminescence of Low-Temperature-Oxidized Porous Si
- Silicon-Monohydride Termination of Silicon-111 Surface Formed by Boiling Water
- Synchrotron-Radiation-Induced Modification of Silicon Dioxide Film at Room Temperature : Beam Induced Physics and Chemistry
- Synchrotron-Radiation-Induced Modification of Silicon Dioxide Film at Room Temperature
- Synchrotron Radiation-Assisted Removal of Oxygen and Carbon Contaminants from a Silicon Surface
- IrO_2/Pb(Zr,Ti)O_3/Pt Capacitor Degradation with D_2 Gas at Elevated Temperature
- Mechanism of Vestibular Adaptation of Fish under Microgravity
- Mechanism of Vestibular Adaptation of Fish under Microgravity (特集:日本の宇宙生物学実験)
- Atomic Step Structure on Vicnal H/Si(111) Surface Formed by Hot Water Immersion
- Large Desorption Yield of Hydrogen Atoms from Silicon Surface in Homogeneous Electron Injection
- Electrical Characteristics of Silicon Devices after UV-Excited Dry Cleaning (Special Issue on Opto-Electronics and LSI)
- High-Speed SOI Bipolar Transistors Using Bonding and Thinning Techniques
- Evaluation of Photoemitted Current from SiO_2 Film on Silicon During Synchrotron Radiation Irradiation
- Chemical Structures of Native Oxides Formed during Wet Chemical Treatments
- Synchrotron Radiation-Assisted Silicon Film Growth by Irradiation Parallel to the Substrate
- Achieving High Current Gain and Low Emitter Resistance with the SiC_x:F Widegap Emitter
- Identification of MOS Gate Dielectric-Breakdown Spot Using High-Selectivity Etching
- A Backscattering-Channeling Study of Thermally Grown Nitride Films on Silicon
- Evaluation of Shot Position Error in Electron Beam Lithography Using Overlay Metrology with 'One-Shot' Inspection Mark
- Impact Ionization in 0.1 μm Metal-Oxide-Semiconductor Field-Effect Transistors
- Oxynitride Pad LOCOS (ON-LOCOS) Isolation Technology for Gigabit DRAMs
- Application of Photo-Assisted Etching Technology to Preferential Etching of Si for Dielectrically Isolated Structure
- Trap Assisted Leakage Mechanism of 'worst' Junction in Giga-bit DRAM Using Negative Word-Line Voltage
- Effects of Reaction Product During Hydrogenation of Si Surfaces in HF Solution
- Simultaneous Temperature Measurement of Wafers in Chemical Mechanical Polishing of Silicon Dioxide Layer
- A pH-Controlled Chemical Mechanical Polishing Method for Thin Bonded Silicon-on-Insulator Wafers
- Influence of Microscopic Chemical Reactions on the Preparation of an Oxide-Free Silicon Surface in a Fluorine-Based Solution
- Influence of Microscopic Chemical Reaction on the Preparation of Oxide Free Silicon Surface in Fluorine-Based Solution
- Effects of Reaction Product During Hydrogenation of Si Surfaces in HF Solution
- Impact of Metal Gate/High-k Interface in Mo Metal Gated MOSFETs with HfO_2 Gate Dielectrics
- Low Contact Resistance Poly-Metal Gate CMOS Using TiN/Thin TiSi_2/Poly-Si Structure
- Fluorine Adsorption and Etching on Si(111):SiH Surface during Immersion in HF Solution
- Low-Contact Resistance Poly-Metal Gate Electrode Using TiN/Thin TiSi_2/Poly-Si Structure
- Fabrication of CoSi2-Buried-Metal-Layer Si Substrates for Infrared Reflection Absorption Spectroscopy by Wafer-Bonding
- Observation of Solution/Si Interface Using IR Spectrochemical Cell During Wet Chemical Oxidation
- Generation of a New Interface State Associated with Ultrathin Gate Dielectrics/Silicon under Electric Stress
- Process Integration Issues on Mo-Metal-Gated MOSFETs with HfO2 High-k Gate Dielectrics
- Key Issues for Manufacturable FeRAM Devices : Novel 0.35um FRAM Technology using Triple Level Aluminum Layer for High Speed and Low Voltage Operation
- Mn2O3 Slurry Reuse by Circulation Achieving High Constant Removal Rate
- Mn2O3 Slurry Achieving Reduction of Slurry Waste
- Si Wafer Bonding with Ta Silicide Formation
- Chemical Structure of Nitrogen Atoms in Thin-Film Nitrided Silicon Dioxide Formed on Silicon Substrate after Hydrogenation Reaction in Hydrofluoric Acid
- Highly Reliable Dynamic Random Access Memory Technology for Application Specific Memory with Dual Nitrogen Concentration Gate Oxynitrides Using Selective Nitrogen Implantation
- In Situ Infrared Spectroscopy on the Wet Chemical Oxidation of Hydrogen-Terminated Si Surfaces
- Wafer Cleaning with Photoexcited Chlorine and Thermal Treatment for High-Quality Silicon Epitaxy