Hydroxyapatite Coating on Titanium Plate with an Ultrafine Particle Beam
スポンサーリンク
概要
- 論文の詳細を見る
A coating technology was developed to form hydroxyapatite (HAp) films on the surface of titanium (Ti) plates using an ultrafine particle (UFP) beam. The UFP beam was composed of HAp particles of submicron size. The dependence of the film's formation on the beam's incident angle was also investigated. A thick HAp film was produced at an incident angle of 0°, but the film did not display good adhesion to the Ti plate. At incident angles of 40° and 60°, the HAp films formed were fine, although not as thick as that formed at 0°. The adhesion strength between the HAp film and the Ti plate was found to be higher than 20 MPa in the films formed at both 40° and 60°.
- Publication Office, Japanese Journal of Applied Physics, Faculty of Science, University of Tokyoの論文
- 2003-02-01
著者
-
TSUKAMOTO Masahiro
Joining & Welding Resarch Institute, Osaka University
-
FUJIHARA Toshiaki
Kinki University
-
KATTO Masahito
Kinki University
-
NAKAYAMA Takeyoshi
Kinki University
-
Miyake Shoji
Joining & Welding Resarch Institute Osaka University
-
Akedo Jun
National Inst. Of Advanced Industrial Sci. And Technol. (aist) Ibaraki Jpn
-
Abe Nobuyuki
Joining & Welding Resarch Institute Osaka University
-
Miyake Shoji
Joining & Welding Research Institute, Osaka University, 11-1 Mihogaoka, Ibaraki, Osaka 567-0047, Japan
-
Tsukamoto Masahiro
Joining & Welding Research Institute, Osaka University, 11-1 Mihogaoka, Ibaraki, Osaka 567-0047, Japan
-
Fujihara Toshiaki
Kinki University, 3-4-1 Kowakae, Higashi-Osaka, Osaka 577-8502, Japan
-
Nakayama Takeyoshi
Kinki University, 3-4-1 Kowakae, Higashi-Osaka, Osaka 577-8502, Japan
関連論文
- Gigahertz-rate optical modulation on Mach-Zehnder PLZT electro-optic modulators formed on silicon substrates by aerosol deposition
- Heat-cycle endurance and in-plane thermal expansion of Al_2O_3/Al substrates formed by aerosol deposition method
- Low Temperature Millimeter-Wave Sintering of Aluminum Nitride with Oxide Additive of CaO-Al_2O_3-Yb_2O_3 System
- OS8(P)-28(OS08W0211) A Study on the Mechanical Properties of Silicon Nitride Ceramics Sintered by 28GHz Millimeter-Wave Heating Method
- Effects of Ion-Beam-Irradiation on Morphology and Densification of CeO_2 Films Prepared by Ion-Beam-Assisted Deposition
- Aerosol Deposition Method for Preparation of Lead Zirconate Titanate Thick Layer at Low Temperature : Improvement of Electrical Properties by Irradiation of Fast Atom Beam and Plasma
- Effect of Thickness on the Piezoelectric Properties of Lead Zirconate Titanate Films Fabricated by Aerosol Deposition Method
- Electron Beam Welding of Zr_Cu_Ni_Al_ Bulk Glassy Alloys
- Influence of Substrate Biasing on (Ba, Sr)TiO_3 Films Prepared by Electron Cyclotron Resonance Plasma Sputtering
- Morphology and Microstructure of Hard and Superhard Zr-Cu-N Nanocomposite Coatings
- Zr-based Hydrogen Absorbing Films Prepared by Ion Beam Assisted Deposition(Physics, Processes, Instruments & Measurements)
- Aerosol Deposition on Transparent Electro-Optic Films for Optical Modulators(Micro/Nano Fabrication,Microoptomechatronics)
- Tribological Property of CeO_2 Films Prepared by Ion-Beam-Assisted Deposition
- What Thickness of the Piezoelectric Layer with High Breakdown Voltage is Required for the Microactuator?
- Hydroxyapatite Coating on Titanium Plate with an Ultrafine Particle Beam
- Influence of Phase Change in Intergranular Oxides to Thermal Conductivity of AIN Sintered by Millimeter-Wave Heating
- Influence of RF Power Supply on ElEctron-Cyclotron-Resonance Plasma with Mirror Confinement for SrTiO_3 Thin Film Formation
- Examination of Meek's Model for Microwave Sintering Mechanism (特集 電磁エネルギー焼結)
- Hydroxyapatite Film Formation by Aerosol Deposition Method(Physics, Processes, Instruments & Measurements, INTERNATIONAL SYMPOSIUM OF JWRI 30TH ANNIVERSARY)
- Formation of Functional Ceramic Films with Ultrafine Particle Beams
- Effect of Applied Magnetic Field on Magnetic Properties of Sm-Fe-N Films Prepared by Aerosol Deposition Method
- Microstructures and Magnetic Properties of Sm-Fe-N Thick Films Produced by the Aerosol Deposition Method
- Pulsed Laser Irradiation for Triggered Discharge in Arc Welding System
- Formation of Carbon Nitride Films by Helicon Wave Plasma Enhanced DC Sputtering
- Decomposition Rate of Si_3N_4 during Microwave Sintering
- P2-50 Time transient analysis of a high speed optical microscanner(Short presentation for poster)
- Influence of Carrier Gas Conditions on Electrical and Optical Properties of Pb(Zr, Ti)O_3 Thin Films Prepared by Aerosol Deposition Method
- Ion Assisted Deposition of Crystalline TiNi Films by electron Cyclotron Resonance Plasma Enhanced Sputtering
- Characteristics of an ECR Plasma Sputtering Source at Low Ar/N_2 Gas Pressures for Thin Film Synthesis
- Studies on Magnetron Sputtering Assisted by Inductively Coupled RF Plasma for Enhanced Metal Ionization
- Inductively-Coupled-Plasma-Assisted Planar Magnetron Discharge for Enhanced Ionization of Sputtered Atoms
- Kinetics of Densification and Phase Transformation at Microwave Sintering of Silicon Nitride with Alumina and Yttria or Ytterbia as Additives (特集 放電焼結の基礎と応用)
- Fabrication and Characterization of Optical Micro-Electro-Mechanical System Scanning Devices Using BaTiO3-Based Lead-Free Piezoelectric-Coated Substrate Sheet by Aerosol Deposition
- Control of Powder Quality as a Method of Improving the Dielectric Properties of (Ba0.6,Sr0.4)TiO3 Thick Films Fabricated by Aerosol Deposition Method
- Electro-Optical Properties and Structures of (Pb, La)(Zr, Ti)O3 and PbTiO3 Films Prepared Using Aerosol Deposition Method
- Powder Preparation in Aerosol Deposition Method for Lead Zirconate Titanate Thick Films
- Fundamental Study of Tandem Electron Beam Welding for Nuclear Fusion and Fission Reactors
- Production of Inductively-Coupled Large-Diameter Plasmas with Internal Antenna
- Periodic microstructures formation on plastic plate by aerosol beam irradiation (溶射特集号)
- Formation of Ni-base self-fusing layers with using direct diode laser (溶射特集号)
- Formation of Hard Surfacing Layers by Electron Beam Cladding with Powder Feeder
- Formation of hydroxyapatite/titania composite film with two aerosol beams (大気圧プラズマを用いたナノマテリアル開発--小特集号)
- Formation of Hard Surfacing Layers of WC-Co with Electron Beam Cladding Method
- Lanthanum-Modified Lead Zirconate Titanate Electro-Optic Modulators Fabricated Using Aerosol Deposition for LSI Interconnects
- Application of Millimeter-Wave Heating to Materials Processing(Recent Trends on Microwave and Millimeter Wave Application Technology)
- Evaluation of Dielectric Properties of Ferroelectric Fine Particles Fabricated by Focused Ion Beam Technique
- Theoretical Investigation of Guide Wave Flowmeter
- Theoretical and Experimental Investigation of Propagation of Guide Waves in Cylindrical Pipe Filled with Fluid
- Electro-Optic Properties of Pb(Zr1-xTix)O3 ($X=0$, 0.3, 0.6) Films Prepared by Aerosol Deposition
- Hydroxyapatite Film Formation on Polylactic Acid Plate by Aerosol Beam Irradiation
- Electro-Optical Properties of (Pb, La)(Zr, Ti)O3 Films Prepared by Aerosol Deposition Method
- Fabrication and Evaluation of Lead-Free Piezoelectric Ceramic LF4 Thick Film Deposited by Aerosol Deposition Method
- Fabrication of Bulk Ceramics by High-Power Millimeter-Wave Radiation
- Alumina Thick Films as Integral Substrates Using Aerosol Deposition Method
- Magnetic Properties and Electromagnetic Wave Suppression Properties of Fe–Ferrite Films Prepared by Aerosol Deposition Method
- Measurements of Ion Energy Distribution Functions in an Radio Frequency Plasma Excited with an m = 0 Mode Helical Antenna and Thin Film Preparation
- Fabrication of (Ba0.6,Sr0.4)TiO3 Thick Films by Aerosol Deposition Method for Application to Embedded Multilayered Capacitor Structures
- Energy Distribution of Ions Incident onto a Dc-Biased Substrate in Electron Cyclotron Resonance Sputtering Plasma for SrTiO3 Thin Film Preparation
- Hydroxyapatite Coating on Titanium Plate with an Ultrafine Particle Beam
- Millimeter-Wave Annealing of SrBi2Ta2O9 Films Prepared by Sol–Gel Method
- Dielectric Characteristics of Ferroelectric Films Prepared by Aerosol Deposition in THz Range
- Structure and Properties of Ti–Si–N Films Deposited by dc Magnetron Cosputtering on Positively Biased Substrates
- Ultra small magneto-optic field probe fabricated by aerosol deposition
- Aerosol Deposition Method for Preparation of Lead Zirconate Titanate Thick Layer at Low Temperature —Improvement of Electrical Properties by Irradiation of Fast Atom Beam and Plasma—
- Tribological Property of CeO2 Films Prepared by Ion-Beam-Assisted Deposition
- Studies on Magnetron Sputtering Assisted by Inductively Coupled RF Plasma for Enhanced Metal Ionization
- Surface Plasmon Resonance in Novel Nanocomposite Gold/Lead Zirconate Titanate Films Prepared by Aerosol Deposition Method
- High-Speed Optical Microscanner Driven with Resonation of Lam Waves Using Pb(Zr,Ti)O3 Thick Films Formed by Aerosol Deposition
- Erratum: "Theoretical Investigation of a Guide Wave Flowmeter"
- Plasma Properties and Ion Energy Distribution in DC Magnetron Sputtering Assisted by Inductively Coupled RF Plasma
- Annealing Effect on 0.5Pb(Ni1/3Nb2/3)O3-0.5Pb(Zr0.3Ti0.7)O3 Thick Film Deposited By Aerosol Deposition Method