Joining Process of Ultrasonic Ceramic Joining
スポンサーリンク
概要
- 論文の詳細を見る
In our previous studies, we have attempted ultrasonic joining of silicon nitride (Si3N4) plates and alumina (Al2O3) plates. We joined these ceramic plates without using any adhesive material in the case where the plates were of the same material. The maximum joint strength was 33 MPa for Si3N4 joints and 30 MPa for Al2O3 joints. Moreover, we analyzed the joined faces using an X-ray photoelectron spectroscope and we found that a new composition should be produced in order to join the ceramic plates together. In this study, we attempted to explain the joining mechanism by means of the results of the X-ray analysis and the observation of the joining process. As a result, we could assume that it is possible to join ceramic plates in spite of the fact that the plates are of different materials. To confirm this, we attempted to join the Si3N4 plate with the Al2O3 plate and the plates were successfully joined together.
- Published by the Japan Society of Applied Physics through the Institute of Pure and Applied Physicsの論文
- 2003-05-15
著者
-
Iijima Mitsuo
Department Of Electronics And Systems Faculty Of Engineering Takushoku University
-
Watanabe Yuji
Department Of Computational Science And Engineering Graduate School Of Engineering Nagoya University
-
Watanabe Yuji
Department of Electronics and Systems, Faculty of Engineering, Takushoku University, 815-1 Tatemachi, Hachioji-shi, Tokyo 193-0985, Japan
-
Iijima Mitsuo
Department of Electronics and Systems, Faculty of Engineering, Takushoku University, 815-1 Tatemachi, Hachioji-shi, Tokyo 193-0985, Japan
関連論文
- ^In Monoclonal Antimyosin Antibody Imaging : Imaging of Myocardial Infarction and Myocarditis : 53th Annual Scientific Session of the Japanese Circulation Society
- Prenatally detected cystic adrenal neuroblastoma
- Metastatic Osteosarcoma in the Jejunum with Intussusception : Report of a Case
- Mycotic Aneurysm of the Aortic Arch due to Salmonella
- Heating of Ferrite Powder by an AC Magnetic Field for Local Hyperthermia (Short Note)
- Effects of Single Administration of a Phosphodiesterase III Inhibitor During Cardiopulmonary Bypass : Comparison of Milrinone and Amrinone
- Early Gastric Cancer Associated with Synchronous Liver Metastasis and Portal Tumorous Embolism : Report of a Case
- -1169-INDIUM-111 LABELED ANTIMYOSIN MONOCLONAL ANTIBODY FAB IMAGING : REPEATED STUDY AND ITS SAFETY : THE 54th ANNUAL SCIENTIFIC MEETING OF THE JAPANESE CIRCULATION SOCIETY
- DETECTION OF ADRIAMYCIN CARDIOTOXICITY WITH INDIUM-111 LABELED ANTIMYOSIN MONOCLONAL ANTIBODY IMAGING
- INDIUM-111 LABELED ANTIMYOSIN MONOCLONAL ANTIBODY SCINTIGRAPHY IN MYOCARDITIS : EXPERIMENTAL AND CLINICAL STUDIES : Cardiomyopathy, Myocarditis : 53 Annual Scientific Meeting, Japanese Circulation Society
- Assessment of Time-Resolved, Dynamic, Contrast-Enhanced MRDSA Using Radial Sliding-Window Reconstruction
- Molecular Mechanisms for Defining Tectum Territory in Chick Embryogenesis
- Molecular mechanisms for defining tectum territory along A-P and D-V axis in chick embryogenesis.
- Synthesis of Fine Mg_Ca_xFe_2O_4 Ferrite Powder Having High Heat Ability under AC Magnetic Field
- EFFICACY OF LAPAROSCOPIC RADIOFREQUENCY ABLATION FOR HEPATOCELLULAR CARCINOMA COMPARED TO PERCUTANEOUS RADIOFREQUENCY ABLATION WITH ARTIFICIAL ASCITES
- Automatic Motion Correction for Quantification of Myocardial Perfusion with Dynamic Magnetic Resonance Imaging
- MR Imaging Features of Solid-pseudopapillary Tumor of the Pancreas
- P-90 IS THERE RACIAL DIFFERENCES IN ADIPOSITY AND SERUM LEPTIN? IF SO, WHEN DOES IT OCCUR? : TWO NATIONS' NUTRITION STUDY
- Metachronous Intraductal Papillary Mucinous Neoplasm with Carcinoma In Situ of the Pancreas Arising Within a Short Interval : Report of a Case
- Quantification of Left Ventricular Volumes from Cardiac Cine MRI Using Active Contour Model Combined with Gradient Vector Flow
- Perfusion CT is superior to angiography in predicting pancreatic necrosis in patients with severe acute pancreatitis.
- Preparation of MgFe2O4 microsphere using spray dryer for embolization therapy application
- Emergent construction of a behavior arbitration mechanism besed on the immune system
- Misexpression of genes in brain vesicles by in ovo electroporation
- High Field Properties of Superconducting Nb_3Ge Films Prepared by Chemical Vapor Deposition
- Ultrasonic Joining of Polytetrafluoroethylene Sheets Using a Newly Designed 50 kHz Flexural-Mode Transducer System
- A Longitudinal-Flexural Complex-Mode Ultrasonic High-Power Transducer System with One-Dimensional Construction
- High-Heat Generation Ability in AC Magnetic Field for Ti Tube Filled with Ferrite Powder
- X-ray Photoelectron Spectroscopic Analysis of Joined Parts in Ultrasonic Joining of Ceramic Plates
- Ultrasonic Joining of Silicon Nitride Plates Without an Adhesive Material Using a 19 kHz Vibration System
- Ultrasonic Joining of Si_3N_4 Plates at 19 kHz Using Al, Cu and Ni Plates as Insert Metal
- Large-Scale Ultrasonic Joining Tool for Joining Plastic Sheets Using a Rectangular Plate Face Vibrating in In-Plane-Mode
- Nuclear translocation of intracellular domain of Protogenin by proteolytic cleavage
- Joining Process of Ultrasonic Ceramic Joining
- Ultrasonic Plastic Welding at 1.2 MHz using a Surface Acoustic Wave Device
- Peculiar Field-Cycle Dependence of Magnetization Observed for Poly(phenyl)acetylene Prepared with a Rh Complex Catalyst
- Ultrasonic Joining of Au Foil using a 2.5 MHz Surface Acoustic Wave Device