Development of New Hybrid VOCs Treatment Process Using Activated Carbon and Electrically Heated Alumite Catalyst
スポンサーリンク
概要
- 論文の詳細を見る
The purpose of this research is the development of a hybrid volatile organic compounds (VOCs) treatment process, which consists of adsorptive separation and catalytic oxidation. This process greatly reduces energy consumption compared with conventional thermal or catalytic combustion processes. Low concentrations of VOCs in polluted air are initially separated and concentrated into a small stream in the adsorptive step, and the concentrated VOCs are oxidized on an electrically heated alumite catalyst. Numerical system evaluation was carried out to estimate the effect of the concentration of VOCs in the air on the material and energy balances. Experimental and theoretical studies were performed on the adsorption of toluene in nitrogen gas, and desorption and concentration by hot nitrogen purging, in fixed-beds charged with activated carbon. A linear driving force mass-transfer model with an averaged overall mass-transfer coefficient was found to provide an acceptable fit to the measured desorption data. The experimental and modeling results were used to assess the influence of the purge gas flow rate and regeneration temperature on the bed length and cyclic steady-state convergence times using cyclic dynamic simulation of thermal swing adsorption. The evaluation results showed that a large amount of energy could be saved, and the unit cost lowered, by combining the adsorption step with electrically heated catalytic oxidation in the treatment of gases with low VOCs concentrations.
- The Society of Chemical Engineers, Japanの論文
著者
-
KAMEYAMA Hideo
Department of Chemical Engineering, Tokyo University of Agriculture and Technology
-
Kameyama Hideo
Department Of Chemical Engineering Faculty Of Engineering Tokyo University Of Agriculture And Techno
-
Sakurai Makoto
Department Of Applied Chemistry College Of Engineering Chubu University
-
Yamaguchi Toshio
Department Of Chemistry Faculty Of Science Fukuoka University
-
Aoki Kazuya
Department of Chemical Engineering, Tokyo University of Agriculture and Technology
-
Yamaguchi Toshio
Department of Chemical Engineering, Tokyo University of Agriculture and Technology
関連論文
- 集団活動でのロジックモデル利用の模擬実験と研究支援システムの発展性検討
- ロジックモデルとバランススコカードの有効性について
- A-9 ロジックモデルとバランススコカードの有効性について(PMコンセプト,日本発信の仕組みP2Mコンセプト明確化と発展的展開-イノベーションを促進し、競争力再生と人材育成に貢献する-)
- Novel Metal Monolithic Anodic Alumina Catalyst for Methane Catalytic Combustion, the External Heat Source for Methane Steam Reforming
- B-3 大学におけるロジックモデルの効用評価と研究支援システムの発展性検討(モデル化、システム化/活性化と組織,経済危機を突破するイノベーション経営の仕組みと仕掛け-新たなものづくり、ことづくり、絆づくり-)
- Thermal Performance of the Plate Fin Type Reactor with Anodized Alumina Catalyst for Methanol Decomposition
- Evaluation of the Selectivity for Methanol Decomposition over Anodized Alminum Plate Catalyst Coated with Silica
- 産学官連携テーマにおけるスキームモデルリスクマネジメント
- スキーム段階におけるICTシステムのサービスモデル策定テンプレートの提案
- 水道施設の更新におけるアセットマネジメント及びP2M手法適用の考察
- Investigation of Anodic Alumina Supported Silver Catalyst for the Selective Reduction of NO by Propene: Promotional Effect of Hydrogen and Effect of Electrical Heating
- Propene-SCR of NO over Electrically Heating Anodic Alumina Supported Silver Catalyst
- Hydrogen Production through Ethanol Steam Reforming on Conducting Heating Alumite Catalysts
- Promotional Effect of Titanium on the Catalytic Performance of Anodic Alumina Supported Silver Catalyst for the Selective Reduction of NO with Propene
- アルマイト触媒の製造技術とエネルギー変換技術と環境浄化技術への応用
- The Effect of SO_2 and H_2O on the SCR-C_3H_6 of NO over a Transition Metals Supported Mesh-type Alumite Catalyst
- 陽極酸化アルミナ触媒を用いたディーゼル排ガスにおけるNOの選択還元
- Selective Catalytic Reduction of Nitric Oxide by Propene over a Cu-Mn-CeO_x/Al_2O_3/Al Alumite Catalyst
- Preparation of Alumite Support and Preliminary Activity Investigation for NO Removal in SCR-HC over Alumite Catalyst
- Cu-Zn/Al_2O_3/Al-Plate Catalyst for a Methanol Reformer
- Performance Simulations of a Compact Plate Methane Steam Reformer Using an Electrically Heated Alumite Catalyst
- Angular Distribution of Ne Metastable Desorption Induced by Exciton Formation at the Surface of Solid Ne--Measurement and Computer Simulation (第35回真空に関する連合講演会プロシ-ディングス)
- Development of CO_2 Adsorbent on Anodic Alumite for Ethanol Steam Reforming
- Study on the Electro-Deposition of Platinum on Anodic Alumite Films for Catalytic Combustion of VOCs
- Sintering Effect of Platinum Catalysts on VOCs' Catalytic Combustion
- Two-Dimensional Coaxial Model for a Cylinder Methane Steam Reformer Using a Novel Plate Catalyst
- Preparation of Platinum Catalysts Supported on Anodized Aluminum for VOC Catalytic Combustion : The Effect of Sintering
- Catalytic Oxidation of Dichloromethane over Anodized Aluminum Film
- Preparation of Anodised Aluminium Catalysts by an Electrolysis Supporting Method for VOC Catalytic Combustion
- Preparation of Platinum Catalysts Supported on Anodized Aluminum for VOC Catalytic Combustion : The Effect of Supporting Method
- Study of Plate-Type Ru/Ceria-Al2O3 Catalysts for Kerosene Steam Reforming
- LEED Observation of Methane Monolayer Physisorbed on Ag(111) (第43回真空に関する連合講演会プロシーディングス--2002年10月16日〜18日,大阪)
- Study of Plate-Type Anodic Alumina Supported Ru Catalyst for Kerosene Steam Reforming under Electric Heating Pattern
- Synthesis of Anodic Alumina Nickel Catalysts and Deactivation Studies over Them for Methane Steam Reforming under Accelerated Degradation Testing
- Plate-Type Anodic Alumina Supported Ruthenium Catalysts for Steam Reforming of Kerosene: Influence of Calcination on Catalysts Reactivity
- Effect of Pore Widening Treatment on BET Surface Area of Rapidly Anodized Alumina Support
- A Plate-Type Anodic Alumina Supported Nickel Catalyst for Methane Steam Reforming
- Selective Catalytic Reduction of Nitric Oxide with Propene Using an Anodic Alumina Supported Silver Catalyst : NO_x Adsorption, TPD and TPSR Studies
- Development of a Methane Steam Reformer Using an Electrically Heated Alumite Catalyst: Start-Up Performance Investigated by the Numerical and Experimental Analysis
- Selective Catalytic Reduction of Nitric Oxide with Propene and Diesel Fuel as Reducing Agents over Anodic Alumina Catalyst
- Otolith Microstructure of the Embryo of the Viviparous Japanese Surfperch Ditrema temmincki(Embiotocidae)
- -0994-CONTINUOUS WAVE DOPPLER ASSESSMENT OF LEFT VENTRICULAR DIASTOLIC FILLING BEFORE AND AFTER PERCUTANEOUS MITRAL VALVULOPLASTY IN PATIENTS WITH MITRAL STENOSIS IN SINUS RHYTHM : THE 54th ANNUAL SCIENTIFIC MEETING OF THE JAPANESE CIRCULATION SOCIETY
- Reactivities of Stable Rotamers. XXXIX. Thermal Decomposition of t-Butyl 3-Methyl-3-(substituted 9-triptycyl)peroxybutanoate Rotamers^
- Coronary Artery Bypass Grafting for a Patient With Tangier Disease
- Mechanism of lumen loss after coronary intervention assessed by intravascular ultrasound : comparison of optimal lesion debulking and debulk-stenting
- Three-dimensional intravasucular ultraound analysis of in-stent neointimal proliferation comparing stenting after directional coronary atherectomy with primary stenting
- Plate Anodic Alumina-supported Nickel Catalysts in Steam Reforming of Methane : Effects of Hydrogen Addition, Electrical Heating, and Pt Doping
- Study of Plate-Type Ru/Ceria-Al_2O_3 Catalysts for Kerosene Steam Reforming
- Study of Plate-Type Anodic Alumina Supported Ru Catalyst for Kerosene Steam Reforming under Electric Heating Pattern
- Reactivity Improvement of Fe-Compounds for the UT-3 Thermochemical Hydrogen Procduction Process
- Development of Platinum Catalyst on an Extremely Thin Alumite Film for VOC Catalytic Combustion
- Non-Equilibrium Hydrogen Production from Ethanol Using CO_2 Absorption Ceramic and Precious Metal Catalysts
- Steam Reforming of Ethanol Using Silica-Coated Alumite Catalysts on Aluminum Plates (JIS A1050)
- Hydrogen Production from Ethanol Using a CO_2 Absorption Ceramic and Base Metal Catalysts
- Steam Reforming of Ethanol Using Silica-Coated Alumite Catalysts on Aluminum Plates (JIS A3003)
- Hydrogen Production from Ethanol Using a Plasma Reactor with an Alumite Catalyst Electrode
- Acute and long-term follow-up results of non-surgical septal myocardial ablation for hypertrophic obstructive cardiomyopathy
- Does optimal lesion debulking need stenting? : one year follow-up results of a prospective randomized trial
- Initial experiences in new atherectomy device Flexi-cut : efficacy on calcified lesions
- Preparation of Ammonium Polyphosphate Form II from the System of Ammonium Orthophosphate-Urea
- Energy Performance Analysis of Heat Transport System Using Methanol Decomposition and Synthesis
- Transluminal Percutaneous Septal Myocardial Ablation in a Patient With Hypertrophic Obstructive Cardiomyopathy
- P2M理論を応用した地域活性化環境プラットフォーム構築
- IDIOPATHIC VENTRICULAR FIRILLATION(IVF) : CLINICAL AND ELECTROPHYSIOLOSICAL ANALYSIS
- Effect of Ru and Pt Addition over Plate-type Catalysts for Methane Steam Reforming during Daily Start-up and Shut-down
- A-5 水道施設の更新におけるアセットマネジメント及びP2M手法適用の考察(社会インフラ/産学官連携トラック)
- Time course of late regression in the post-interventional coronary artery : Five-year follow-up analysis from Prevention of Coronary Atherosclerosis Study
- Characteristics of University Spin-offs in Chemistry and their Business Relationships with Manufacturers
- Development of Plate-Fin-Type Methanol Reformer
- B-8 スキーム段階におけるICTシステムのサービスモデル策定テンプレートの提案(P2M理論研究トラック)
- A-6 産学官連携テーマにおけるスキームモデルリスクマネジメント(社会インフラ/産学官連携トラック)
- A-6 P2M理論を応用した地域活性化環境プラットフォーム構築(グローバル競争/環境プロジェクト研究トラック)
- Novel Metal Monolithic Anodic Alumina Catalyst for Methane Catalytic Combustion, the External Heat Source for Methane Steam Reforming
- Plate-Type Anodic Alumina Supported Ruthenium Catalysts for Steam Reforming of Kerosene : Influence of Calcination on Catalysts Reactivity
- Hydrogen Permeability and Membrane Durability of Novel Pd/γ-Alumina Graded Membrane When a Sweep Gas in Used
- Propene-SCR of NO over Electrically Heating Anodic Alumina Supported Silver Catalyst
- Investigation of Anodic Alumina Supported Silver Catalyst for the Selective Reduction of NO by Propene : Promotional Effect of Hydrogen and Effect of Electrical Heating
- Catalytic Oxidation of Volatile Organic Compounds over Co-Based Catalysts Supported on Charcoal from Thinned Wood
- 開発途上国における開発計画策定支援の意義とその実行へのPPP適用に関する研究 : 3Sモデルによる開発プロセスの適正化
- ODA事業におけるステークホルダーマネジメントの実践構造化 : 環境社会配慮における合意形成プロセスの最適化
- P2M理論を適用することによる「三位一体」経営の提唱
- P2Mからみた社会的環境プラットフォーム構築へのアプローチ
- A4 特許事務所をプラットフォーム・リーダーとするプラットフォームの提唱(戦略シナリオトラック)
- A3 TRIZを活用した研究開発マネジメントの提唱(戦略シナリオトラック)
- D2 企業R&Dにおけるプラットフォームマネジメントの実践(組織と意思決定トラック)
- C4 P2Mからみた社会的環境プラットフォーム構築へのアプローチ(システムズ・アプローチ研究トラック)
- C1 開発途上国における開発計画策定支援の意義とその実行へのPPP適用に関する研究 : 3Sモデルによる開発プロセスの適正化(システムズ・アプローチ研究トラック)
- D3 P2M理論によるITサービス産業の水平連携プラットフォームの構築(組織と意思決定トラック)
- B3 P2M理論を適用することによる「三位一体」経営の実現可能性(戦略経営研究トラック)
- A4 ODA事業におけるステークホルダーマネジメントの実践構造化 : 環境社会配慮における合意形成プロセスの最適化(ミッション方法論研究/プロジェクト組織研究トラック)
- Characteristics of University Spin-Offs in Chemistry and Their Business Relationships with Manufacturers
- Operating Temperature Conditions for Periodic Temperature Cycling in a Microreactor
- Selective Catalytic Reduction of Nitric Oxide with Propene Using an Anodic Alumina Supported Silver Catalyst : NO_x Adsorption, TPD and TPSR Studies
- Synergistic Effect of Copper and Cobalt in Cu–Co Bulk Oxide Catalyst for Catalytic Oxidation of Volatile Organic Compounds
- Steam Methane Reforming Using an Anodic Alumina Supported Nickel Catalyst (Ni/Al2O3/Alloy): Analysis of Catalyst Deactivation
- Development of New Hybrid VOCs Treatment Process Using Activated Carbon and Electrically Heated Alumite Catalyst
- Hydrogen Production through Ethanol Steam Reforming on Conducting Heating Alumite Catalysts
- Catalytic Oxidation of Volatile Organic Compounds over Co-Based Catalysts Supported on Charcoal from Thinned Wood
- Anodic Alumina Catalyst Support with High Heat-Resistance for Hydrocarbon Steam Reformers
- Chemical reaction cycles for the recovery of low-level thermal energy.