Development of a method for testing very high-efficiency membrane filters for ultrafine aerosol particles.
スポンサーリンク
概要
- 論文の詳細を見る
A method for testing membrane gas filters having very high collection efficiency has been developed. These filters have high pressure drop together with their high collection efficiency. As a test aerosol, NaCl and ZnCl<SUB>2</SUB> particles generated by an evaporation-condensation type aerosol generator were used. They had a geometric standard deviation ranging from 1.1 to 1.4. These aerosols were supplied into pressurized clean air (about 3 × 10<SUP>4</SUP> Pa gauge) by use of an ejector to overcome the pressure of the filter. Because of extremely low aerosol concentrations at the filter outlet, a high-flow rate CNC (condensation nucleus counter: 1 to 2 <I>l</I>/mm) which can detect aerosols of very low concentration was used. Measurement of the filter performance showed that the penetration by particles depended upon the structure of the membrane, but not upon pressure drop. As an example, a penetration of about 2 × 10<SUP>–10</SUP> for 0.02 <I>μ</I>m diameter particles at a pressure drop of 3.1 × 10<SUP>4</SUP> Pa gauge and a filtering velocity of 0.68 m/s has been observed.
- The Society of Chemical Engineers, Japanの論文
著者
-
Shimada Manabu
Department Of Chemical Engineering Faculty Of Engineering Hiroshima University
-
Okuyama Kikuo
Department Of Chemical Engineering Faculty Of Engineering Hiroshima University
-
Kousaka Yasuo
Department Of Chemical Engineering Osaka Prefecture University
-
Takii Yoshimasa
Department of Chemical Engineering, University of Osaka Prefecture
関連論文
- Preparation of functional nanostructured particles by spray drying
- Preparation of Submicron- and Nanometer-Sized Particles of Y_2O_3:Eu^ by Flame Spray Pyrolysis Using Ultrasonic and Two-Fluid Atomizers
- Continuous Single-Step Fabrication of Nonaggregated, Size-Controlled and Cubic Nanocrystalline Y_2O_3:Eu^ Phosphors Using Flame Spray Pyrolysis
- Fabrication and Characterization of SiO_2 Particles Generated by Spray Method for Standards Aerosol
- One-Step Synthesis for Zn_2SiO_4 : Mn Particles 0.3-1.3 μm in Size with Spherical Morphology and Non-Aggregation
- Direct Measurement of Nucleation and Growth Modes in Titania Nanoparticles Generation by a CVD Method
- Direct synthesis of highly crystalline transparent conducting oxide nanoparticles by low pressure spray pyrolysis
- Nanoparticle Synthesis by Ionizing Source Gas in Chemical Vapor Deposition
- Gas-Phase Nucleation in GaAs Thin Film Preparation by Metal Organic Chemical Vapor Deposition
- Numerical Simulations of Films Formed by Cluster/Particle Co-Deposition in Atmospheric-Pressure Chemical Vapor Deposition Process Using Organic SIlicon Vapors and Ozones Gas
- Morphology Control of Films Formed by Atmospheric-Pressure Chemical Vapor Deposition Using Tetraethylorthosilicate/Ozone System
- Film Formation by a New Chemical Vapor Deposition Process Using Ionization of Tetraethylorthosilicate
- Sintering behavior of spherical aggregated nanoparticles prepared by spraying colloidal precursor in a heated flow
- Precursors in Atmospheric-Pressure Chemical Vapor Deposition of Silica Films from Tetraethylorthosilicate/Ozone System
- Particle Generation and Film Formation in an Atmospheric-Pressure Chemical Vapor Deposition Reactor Using the Tetraethylorthosilicate (TEOS)/He, TEOS/O_2/He, and TEOS/O_3/He Systems
- Gas-Phase Nucleation in an Atmospheric Pressure Chemical Vapor Deposition Process for SiO_2 Films Using Tetraethylorthosilicate (TEOS)
- A Role of Template Surface Charge in the Preparation of Porous and Hollow Particles Using Spray-drying
- Nanosized Polymer Particle-facilitated Preparation of Mesoporous Silica Particles Using a Spray Method
- Photoluminescence Properties of Ce_Tb_xMgAl_O_ Phosphor Particles Prepared by Spray Pyrolysis
- The Influence of the Synthetic Conditions of Chemical Vapor Synthesis on the Size of Gallium Nitride Nanoparticles
- Observation of Heat-Induced Particle Resuspension and Transport in a Plasma Chemical Vapor Deposition Chamber
- Effects of Mobility Changes and Distribution of Bipolar Ions on Aerosol Nanoparticle Diffusion Charging
- Development of an LDMA-FCE System for the Measurement of Submicron Aerosol Particles
- One-step Preparation of BaTiO_3 Nanoparticles by Liquid Source Chemical Vapor Deposition
- Templated Synthesis of Silica Hollow Particles by Using Spray Pyrolysis
- Characterization of silica-coated Ag nanoparticles synthesized using a water-soluble nanoparticle micelle
- Synthesis of nanocrystalline GaN from Ga_2O_3 nanoparticles derived from salt-assisted spray pyrolysis
- Influence of Synthesis Conditions on the Characteristics of Nanoparticles Produced in a Nonequilibrium Plasma Field
- Formation of Submicron Copper Sulfide Particles Using Spray Pyrolysis Method
- Measurement of Cluster Ions and Residue Nanoparticles from Water Samples with an Electrospray/Differential Mobility Analyzer
- Effect of X-ray energy and ionization time on the charging performance and nanoparticle formation of a soft X-ray photoionization charger
- Numerical Evaluation of Silicon-Thin Film Growth from SiHCl_3-H_2 Gas Mixture in a Horizontal Chemical Vapor Deposition Reactor
- Preparation of Bi-Pb-Ca-Sr-Cu-O Superconducting Thick Films Using Spray-Pyrolyzed Fine Powders
- Direct Preparation of Fine Powders of the 80 K Superconducting Phase in the Bi-Ca-Sr-Cu-O System by Spray Pyrolysis
- Direct Preparation of Uniformly-Distributed YBa_2Cu_3O_ Powders by Spray-Pyrolysis : Electrical Properties of Condensed Matter
- Photoluminescent ZrO2:Eu3+ Nanofibers Prepared via Electrospinning
- SIZE CHANGE OF VERY FINE SILVER AGGLOMERATES BY SINTERING IN A HEATED FLOW
- Wall Deposition of Ultrafine Aerosol Particles by Thermophoresis in Nonisothermal Laminar Pipe Flow of Different Carrier Gas
- Preparation of microencapsulated powders by an aerosol spray method and their optical properties
- Heating Profile Effect on Morphology, Crystallinity, and Photoluminescent Properties of Y2O3:Eu3+ Phosphor Nanofibers Prepared Using an Electrospinning Method
- Plasma Synthesis of Light Emitting Gallium Nitride Nanoparticles Using a Novel Microwave-Resonant Cavity
- SIMULATION OF A TRANSIENT HETEROGENEOUS PHASE TRANSITION
- DETERMINING THE PHASE TRANSITION OF CONDENSATE FORMED BY HETEROGENEOUS NUCLEATION OF CONDENSABLE VAPORS ONTO A COLD SUBSTRATE
- A THEORETICAL EVALUATION OF LIQUID CONDENSATE FORMATION BY HETEROGENEOUS NUCLEATION FROM A BENZENE AND CYCLOHEXANE VAPOR MIXTURE
- HETEROGENEOUS NUCLEATION CHARACTERISTICS OF MIXED VAPOR OF BENZENE AND CYCLOHEXANE ON A COLD SUBSTRATE
- OBSERVATIONS OF HETEROGENEOUS NUCLEATION OF WATER VAPOR ON A COLD SUBSTRATE
- DETERMINATION OF THE CRITICAL SUPERSATURATION RATIO IN HETEROGENEOUS NUCLEATION OF BENZENE VAPOR ON A COLD SUBSTRATE
- Formation of Fine Particles of Zinc Sulfide from Thiourea Complexes by Spray Pyrolysis
- Biopolar Charging of Aerosol Nanoparticles by a Soft X-ray Photoionizer
- Molecular Flow Analysis in Orifice-Restricted Tube Using Maxwellian Distribution Function
- Nanometer coating on aerosol particles
- Progress in developing spray-drying methods for the production of controlled morphology particles : From the nanometer to submicrometer size ranges
- Indium Tin Oxide Nanofiber Film Electrode for High Performance Dye Sensitized Solar Cells
- A Free Molecular Flow Characteristic through a Conduit with an Orifice-Restricted Exit
- A new sizing technique of aerosol particles-line start sedimentation type using an ultramicroscope
- Flame Spray Pyrolysis for Preparing Red-Light-Emitting, Submicron-Sized Luminescent Strontium Titanate Particles
- TURBULENT COAGULATION OF AEROSOLS IN A STIRRED TANK
- CHANGE IN PARTICLE SIZE DISTRIBUTIONS OF POLYDISPERSE AEROSOLS UNDERGOING BROWNIAN COAGULATION
- Simultaneous Observation of Molecular Contamination Behavior in Semiconductor Clean room Using Quartz Crystal Microbalance
- Photoluminescence Characteristics of Macroporous Eu-Doped Yttrium Oxide Particles Prepared by Spray Pyrolysis
- Decolorization of beads-milled TiO_2 nanoparticles suspension in an organic solvent
- Influence of Polymer Decomposition Temperature on the Formation of Rare-Earth Free Boron Carbon Oxynitride Phosphors
- Time-Dependent Airborne Organic Contamination on Silicon Wafer Surface Stored in a Plastic Box
- Observation of Adsorption Phenomena of Dibutyl Phthalate Molecules on Si Surface Using Quartz Crystal Microbalance Method
- Adsorption and Desorption of Dibutyl Phthalate on Si Surface Measured in Controlled Atmosphere using Quartz Crystal Microbalance Method
- Molecular Flow Analysis in Orifice-Containing Tube Using Maxwellian Distribution Function.
- Photoluminescence Properties of Submicrometer Phosphors with Different Crystallite/Particle Sizes
- Development of a method for testing very high-efficiency membrane filters for ultrafine aerosol particles.
- Measurement of electric charge of aerosol particles generated by various methods.
- The effect of neighbouring fibers on the single fiber inertia-interception efficiency of aerosols.
- EXPERIMENTAL STUDY OF THERMOPHORESIS OF AEROSOL PARTICLES
- Effects of brownian coagulation and brownian diffusion on fine particle size analysis by sedimentation method.
- Dispersion mechanism of aggregate particles in air.
- Effect of Brownian diffusion on electrical classification of ultrafine aerosol particles in differential mobility analyzer.
- Application of particle enlargement by condensation to industrial dust collection.
- PREDICTION OF COLLECTION EFFICIENCY OF AEROSOLS BY HIGH-POROSITY FIBROUS FILTER
- Re-entrainment of small aggregate particles from a plane surface by air stream.
- Response of cigarette smoke particles to change in humidity.
- EFFECT OF BROWNIAN COAGULATION AND BROWNIAN DIFFUSION ON GRAVITATIONAL SETTLING OF POLYDISPERSE AEROSOLS
- Nanoparticle Synthesis by Ionizing Source Gas in Chemical Vapor Deposition