船体用鋼板の疲労強度について
スポンサーリンク
概要
- 論文の詳細を見る
This paper deals with the results of the fatigue tests on four kinds of structural steels for ships, including ordinary mild steels and high strengh steels. Main objective of this research is to investigate the influence of notch and welding on the fatigue strength of the steels. The following conclusions were obtained from the experimental results.1) In the case of pulsating tension tests, the S-N curves converge approximataly toward the tensile strength of steels (almost parallel to the N-axis at stresses higher than 90 per cent of the tensile strength), where no significant difference was found in the fatigue strength between notched or welded specimens and plain specimens. In general, the low cycle fatigue strength of steels is governed by their tensile strength.2) When the maximum stress is lower than 90 per cent of the tensile strength of steel, either notched or welded specimens showed lower strength than the plain specimens. It was also found that the significant decrease of the fatigue strangth in highly stress-concentrated specimens appeared in comparatively shorter life than that of less stress-concentrated specimens.3) The fatigue strength of plain specimens is approximately proportional to the tensile strength of the material.4) In the case of notched specimens, the fatigue strength for a large number of cycles is not proportional to the tensile strength of steels. The difference of the endurance limit between mild steels and high steels is not so pronounced as in the case of plain specimens. This tendency becomes remarkable in sharply notched specimens.5) Except in the case of heat-treated high strength steels, no significant influence of the metallurgical change on the fatigue strength of steels was observed, and therefore it is considered that the decrease in the fatigue strength of the welded specimens is mainly caused by stress concentration i. e. geometrical effect of the weld metals. On the other hand, welded joints of a heat-treated high strength steel showed considerable decrease of the fatigue strength as influenced by both metallurgical and geometrical defects due to welding.6) Butt-welded joints by manual welding indicated higher fatigue strength than automatically welded specimens because of the difference in the form of the reinforcement.
- 社団法人日本船舶海洋工学会の論文
著者
-
山口 勇男
日本海事協会
-
新田 顕
日本海事協会技術研究所
-
寺田 泰治
日本海事協会
-
寺田 泰治
財団法人日本海事協会
-
新田 顕
日本海事協会開発部
-
新田 顕
(現)日本舶用品検定協会専務理事:日本海事協会開発部
-
山口 勇男
日本海事協会技術研究所
関連論文
- (6)船体構造における疲労事故とその対策(脆性破壊と疲労に関するシンポジウム案内)(9月13,14日開催予定の標記シンポジウム講演の梗概)
- 船体用大径鋲に関する研究(第3報, 完結) : 大型鋲継手試験片による実験
- 油漕船の横強度に関する実船計測ならびにその解析
- 船体構造に於ける縱材及び横材の相互干渉に就いて
- 進水時船體應力測定用電気計器の試作報告 : 計器小委員會報告第1報
- 超大型油槽船「日石丸」の強度実験
- コンテナ船の横強度実船試験
- 「ガーダウェブ等の開孔基準」に対する検討
- 上部構造端部損傷について
- 隆起甲板について
- 大型船における縦通隔壁の有効性に関する実験的研究
- 超高圧海水ポンプの開発
- 平板の水面衝撃について
- 速報1 : 平板の水面衝擊
- 溶接構造用強力アルミニウム合金の話
- 大型船の横桁材におけるスロット周辺の損傷防止に関する検討(その1)
- セミメンブレンLPG船の就航中計測
- IACS縦強度統一規則とその背景(技術規則解説)
- 海洋汚染防止のための原油洗浄方式に関する調査(技術一般)
- トリピングブラケットの座屈強度と桁に対する支持効果について
- 信頼性解析に基づく船体構造設計について
- 船体構造強度の信頼性解析
- LNG船構造解析プログラム(技術一般)
- 波浪衝撃水圧発生装置の試作開発に関する研究(昭和48年学協会刊行物掲載論文再録集)
- 波浪衝撃水圧発生装置の試作開発に関する研究
- 船体横強度のトータルシステムについて
- 船体縦強度解析に関するトータルシステム : タンカーの縦強度について
- NKにおける船体縦強度解析に関するトータルシステムについて(構造解析の電算化小特集)
- 船体強度に関する計測とモニターシステムの開発
- 船体強度に関する長期実船計測(損傷関係)
- 自動車運搬船の横強度に関する実船計測
- コンテナ船の実船計測
- 疲労による溶接構造物の損傷例(溶接構造物の疲労強度)
- 溶接構造物の疲労損傷例(溶接構造物の疲労強度とその改善方法)
- 2 溶接構造物の疲労損傷例
- 船体横強度設計法
- 第 XIII 委員会出席報告 : Fatigue Testing(1968 年 IIW 年次大会(ワルシャワ)出席報告)
- 船体構造部材の疲労損傷例(溶接構造物の破損事故)
- 船体構造の疲労強度とその対策
- 船体溶接構造の疲労強度
- 塑性疲労による損傷について
- 船体横強度近似計算法について(第2報) : 端部変断面部および剪断変形の影響について
- 船体横強度近似計算法について(第1報) : 貨物船における縦部材の影響について
- 肘板を有する骨組構造物の曲げモーメント分布について
- 肘板を有する固定梁の実験について
- 高張力鋼を船体に使用するときの問題点
- FRP船におけるサンドイッチ構造について(技術一般)
- ERP救命艇の実艇強度試験
- バルクキャリヤーの倉内肋骨の強度
- 耐食アルミニウム合金加工硬化材の溶接継手の強度について
- 油槽船における部材結合部の応力分布とその近似計算法について
- 肘板付骨組構造の強度計算法について
- 肘板付梁に関する研究
- 船体用鋼板の疲労強度について
- 汽船Lukuga号の運航性能と海上試運転
- ビームニーおよび他のブラケット結合
- 船体横強度展望
- 組立梁の強度及び剛性
- サルファークラックが鋼材疲労強度に及ぼす影響
- LNG船の構造解析
- 自動車運搬船の横強度に関する実船計測
- 船体構造の座屈強度解析について
- コンテナ船縦強度の実船計測および長期予測
- 彎曲部における桁の面材の有効幅
- コンテナ船の横強度解析及び実船計測
- 超大型油送船日石丸の実船計測
- 板構造の座屈に関するシンポジウムの概要紹介
- 桁板構造の最終強度に関する研究(その3) : 桁の横倒れ不安定現象について
- 桁板構造の最終強度に関する研究(その2)
- 二重底構造の強度に関する実船試験
- 二重底構造の強度に関する実船試験
- 桁板構造の最終強度に関する研究(その1)
- 軸力と曲げをうける混用梁の塑性強度について
- 上部構造の有効性について