<研究>青化法に於ける金の溶解に關する基礎的研究(第7報) : 金鑛青化試験に於ける金銀の溶解に及ぼす汚染不純物の影響
スポンサーリンク
概要
- 論文の詳細を見る
The cyanidation tests were undertaken with the aim of examining the effect of the following salts influencing the extraction of gold and silver from ores by means of a miniature Pachuca tank. (I) Additional amount of xanthate, (II) sodium sulfide, (III) potassium ferrocyanide, (IV) potassium zincocyanide, (V) double cyanide of copper and potassium, (VI) potassium thiocyanate, (VII) of potassium sulfate, (VIII) simultaneous addition of some impurities above-mentioned. The ores used were from T, S and O mines. As they consisted principally of silica with small amount of sulfides, the degree of contamination in solution caused by the cyanidation of these ores alone was very small. The tests were thus made by adding intentionally individual impurities mentioned above to cyanide solutions. These tests were made under the following conditions : (1) Pulp agitated for 6hrs. (2) 50 or 100 grams of ore and 500 cc of solution used. (3) Constant cyanide strength of 0.086 per cent KCN used in all tests. The following results are thereby obtained. (1) Xanthate decreases considerably the dissolution rates of gold and silver, in both cases of cyanidation after stirring ores in dilute xanthate solution, filtering, and then washing, and of cyanidation in coexistence with xanthate ions in solution after pre-conditioning. On the other hand, it decreases slightly in the case of cyanidation in coexistence with xanthateions without pre-conditioning. (2) The existence of sodium sulfide is fatal to the dissolution of gold and silver and this coincides nearly with the result of the fundamental experiment of the author (see the fifthreport). The further addition of lead acetate to this solution removes the fatal action of sodium sulfide, but its amount in excess causes again a retarding action probably due to the passive state introduced on the surface of sold and silver. (3) The addition of potassium ferrocyanide has little effect on the dissolution and in the case of O ore it quickens in some degree the dissolution, most coinciding with the result of the fundamental experiment. (4) Potassium zincocyanide has also little effect on the dissolution rates of gold and silver. The addition of free alkali to the solution containing potassium zincocyanide alone cause the yield of potassium cyanide, resulting in the dissolution of gold and silver. (5) The double cyanide of copper and potassium has little effect on the dissolution rate of gold in the case of T and S ores, while it retards remarkably the dissolution of gold and silver in the case of O ore. (6) Both potassium thiocyanate and sulfate have no effect on the dissolution which nearly coincides with the results of the fundamental experiments. (7) Some experiments, in the case of simultaneous addition of above-mentioned impurities except xanthate and sodium sulfide, show that the dissolution of gold and silver is retarded not greatly in spite of great contamination, and that lead acetate, prior to all other coexistent impurities, exerts the effect characteristic of it.
- 東北大学の論文
- 1950-09-12
著者
関連論文
- 選択硫酸化による複雑硫化鉱処理法の検討 : 酸濃度および処理温度について
- 黒鉱精鉱と鉛, 亜鉛を含む銅マットの減圧処理について
- 拡散係数の計算式の適用性
- 塩化揮発法に関する基礎的実験 : 塩化カルシウムの酸化反応について
- 黒鉱系銅精鉱の溶錬産出物に関する研究(第3報) : 自溶炉ボイラ煙灰の組織について
- 黒鉱系銅精鉱の溶錬産出物に関する研究(第1報) : 銅スラグの組織について
- 黒鉱系銅精鉱の溶錬産出物に関する研究(第2報) : スラグ, マット中の硫化物相について
- 溶融銅中の鉄の活量測定(1,100°, 1,200℃)
- 金銀鑛青化試驗報告
- 複雜硫化鑛處理の研究(第3報) : 撰擇硫酸化處理並に亞鉛電解に就て
- 青化法に於ける金の溶解に關する基礎的研究(第7報) : 金鑛青化試験に於ける金銀の溶解に及ぼす汚染不純物の影響
- 選鉱製錬研究所前併任教授
- 銅転炉スラグの脱銅に関連する二三の実験
- 真空熔解による粗銅の精製について
- 鉄珪酸塩スラグへの金属銅の溶解に関する二三の実験(その2)
- 鉄珪酸塩スラグへの金属銅の溶解に関する二三の実験(その1)
- 銅製錬に於けるFeSの酸化に關する二三の化學熱力學的考察
- 銅の熔錬に関する研究-2-
- 銅の熔錬に関する研究-1-
- 硫化第一鐵の酸化に於ける自觸過程について
- 故鉛脱錫に關する實験
- 青化溶液に於ける金の溶解に關する研究(第 4 報) : 金粒の大さとその溶解時間に就ての考察
- Co 鑛製錬研究(第二編)(金門島産コバルト鑛製錬研究)