Effect of FeO in Dripping Slag on Drainage Ability of Slag
スポンサーリンク
概要
- 論文の詳細を見る
Japanese iron and steelmaking industry has to reduce CO2 emission by 11.5% in 2010 relative to the level of emissions in 1990. Stable blast furnace operation is required to reduce energy consumption and CO2 emission in iron and steelmaking industry. For the stable blast furnace operation, precise controlled drainage is one of the important factors. However, there are many unrevealed phenomena in the hearth to perform the stable operation. Therefore, in this work, the effect of iron and slag dripping pattern, FeO concentration in the dripping slag on the iron and slag surfaces, thermal properties of refractory and brick on drainage temperature, temperature distribution in the hearth, temporal variation of iron and slag drainage rates and interfaces shapes were investigated by using tree-dimensional mathematical model.The results indicate that more than 2 mass% FeO in dripping slag will cause deterioration of slag drainage ability due to high slag viscosity around tapholes. Continuous monitoring of FeO concentration in the tapping slag is effective to prevent deterioration of slag drainage ability. The trends of the other side of tapping taphole temperature were varied dramatically according with FeO concentration in the dripping slag. Even in the case of 0 mass% FeO in the dripping slag, there is a solidified slag near the hearth wall except around the tapholes. A peripheral distribution pattern will result in a stable drainage. Slag, which dripped on near the other side of the tapping taphole, stays around the taphole, and does not drain from the tapping taphole located opposite side.
- The Iron and Steel Institute of Japanの論文
著者
-
Nishioka Koki
Department of Materials Science and Engineering, Faculty of Engineering, Kyushu University
-
Shimizu Masakata
Department of Materials Science and Engineering, Faculty of Engineering, Kyushu University
-
Maeda Takayuki
Department Of Material Science And Engineering Kyushu University
-
Nishioka Koki
Department Of Material Science And Engineering Kyushu University
-
Shimizu Masakata
Department Of Material Science And Engineering Kyushu University
関連論文
- Development of Fe Base Phase Change Materials for High Temperature Using Solid–Solid Transformation
- Wetting and Penetration Behavior of Calcium Ferrite Melts to Sintered Hematite
- Effect of Carbon Structure Crystallinity on Initial Stage of Iron Carburization
- Effect of Adding Moisture and Wettability on Granulation of Iron Ore
- Modeling of Dripping Behavior in Particles Packed Bed Filled with Immiscible Fluid
- Effect of Granulation Condition and Property of Raw Material on Strength of Granulated Particle by Tumbling Granulation
- Reaction Behavior during Heating Waste Plastic Materials and Iron Oxide Composites
- Gasification and Reduction Behavior of Plastics and Iron Ore Mixtures by Microwave Heating
- Kinetic Analysis of Spherical Wustite Reduction Transported with CH_4 Gas
- Application of Square-wave Pulse Heat Method to Thermal Properties Measurement of CaO-SiO_2-Al_2O_3 System Fluxes
- A Three-dimensional Mathematical Modelling of Drainage Behavior in Blast Furnace Hearth
- Formation Rate of Calcium Ferrite Melt Focusing on SiO_2 and Al_2O_3 Component
- Dezincing Behavior from Iron and Steelmaking Dusts by Microwave Heating
- Dezincing Behavior from Iron and Steelmaking Dusts by Microwave Heating
- Development of Fe Base Phase Change Materials for High Temperature Using Solid-Solid Transformation
- Effect of Slag Melting Behavior on Metal-Slag Separation Temperature in Powdery Iron, Slag and Carbon Mixture
- Development of Secondary-fuel Injection Technology for Energy Reduction in the Iron Ore Sintering Process
- Diffusion Behaviors of He and CH4 in Air Flow through Packed Bed
- Effects of Charcoal Carbon Crystallinity and Ash Content on Carbon Dissolution in Molten Iron and Carburization Reaction in Iron-Charcoal Composite
- Effect of CO Gas Concentration on Reduction Rate of Major Mineral Phase in Sintered Iron Ore
- Effect of FeO in Dripping Slag on Drainage Ability of Slag
- Preface to the Special Issue on "Innovative Reduction Technology of Iron Ore for Mitigation of CO2 Emission in Ironmaking"
- Effect of Various In-furnace Conditions on Blast Furnace Hearth Drainage
- Effects of Charcoal Carbon Crystallinity and Ash Content on Carbon Dissolution in Molten Iron and Carburization Reaction in Iron-Charcoal Composite
- Numerical Study on Pulverized Biochar Injection in Blast Furnace