Thermodynamics of Copper Dissolution into MnO–SiO2–MnS Inclusion System
スポンサーリンク
概要
- 論文の詳細を見る
Recently, a new process has been introduced to control α–γ transformation of steels using cuprous sulfide precipitates on the MnO bearing oxide inclusion as well as MnS. In order to optimize the composition of inclusions, the solubility of copper into MnO–SiO2–MnS system were measured at 1523 K and a dissolution mechanism of copper into an oxy-sulfide melts and cuprous sulfide capacity has been proposed. The solubility of copper increased with an increase in MnO/(MnO+SiO2) ratio and showed a maximum solubility at MnO and MnS doubly saturated composition, which was consistent with the maximum precipitation ratio of CuS. Deliberating an oxy-sulfide melts saturated with MnS, MnO, and SiO2 at 1523 K, the phase diagram for the MnO–SiO2–MnS system indicated that the activity coefficient of cuprous sulfide in an oxy-sulfide melts was dependent on the activity of MnO and the activity coefficient of MnS. The dissolution mechanism of copper into a MnO–MnS inclusion system was confirmed and cuprous sulfide capacity was also defined from the reaction mechanism. Cuprous sulfide capacity for the MnO–MnS bearing inclusion strongly depends on stability of sulfide and basicity. The experimental results revealed that the optimized composition for inclusion to dissolve copper was (mass%MnO)=43.6, (mass%SiO2)=1.8 and (mass%MnS)=54.6. Consequently, it could be proposed that the harmlessness of copper in scrap and dispersion strengthening could be possible by using the non-metallic inclusion technique.
著者
-
Park Jin
Department of Internal Medicine, Sejong General Hospital
-
Park Joo
School of Materials Science and Engineering, University of Ulsan
-
Lee Young
Technical Research Laboratories, POSCO
-
Jung Sung
Graduate Institute of Ferrous Technology (GIFT), Pohang University of Science and Technology (POSTEC
-
Min Dong
Department of Metallurgical Engineering, Yonsei University
関連論文
- Periodic Variation and Its Effect on Management and Prognosis of Korean Patients With Acute Myocardial Infarction
- Carbide Capacity of CaO–SiO2–MnO Slag for the Production of Manganese Alloys
- Thermodynamics of Copper Dissolution into MnO–SiO2–MnS Inclusion System
- Disc Degeneration in the Rabbit : A Biochemical and Radiological Comparison Between Four Disc Injury Models
- BMP-2 and CDMP-2 : stimulation of chondrocyte production of proteoglycan
- Incidence of hip fractures in Korea
- Periodic Variation and Its Effect on Management and Prognosis of Korean Patients With Acute Myocardial Infarction
- A Direct Estimation Method of Second Order Plus Time Delay Model Parameters for PID Controller Autotuning
- Endogenous expression of TRPV1 channel in cultured human melanocytes
- BMP-2 and CDMP-2 : stimulation of chondrocyte production of proteoglycan
- Influence of MgO and Al_2O_3 Contents on Viscosity of Blast Furnace Type Slags Containing FeO
- Influence of Basicity and FeO Content on Viscosity of Blast Furnace Type Slags Containing FeO
- Thermodynamic Behavior of Carbon in Molten Slags
- Reduction Behavior of EAF Slags Containing Cr_2O_3 Using Aluminum at 1793K
- FT-IR Spectroscopic Study on Structure of CaO-SiO_2 and CaO-SiO_2-CaF_2 Slags
- Carbide Capacity of CaO-Al_2O_3-CaF_2 Slag at 1773K
- Structural Investigation of CaO-Al_2O_3 and CaO-Al_2O_3-CaF_2 Slags via Fourier Transform Infrared Spectra
- Sulfide Capacity and Phase Equilibria of MnO-TiO_2MnS System at 1723 K
- Carbide Capacity of CaO-SiO_2-CaF_2 (-Na_2O) Slags at 1773K
- EFFECT OF RELATIVE HYDROPHILICITY ON ENZYMATIC ACTIVITY OF MODIFIED CELLULASE
- ADSORPTION CONTROL OF CELLULASE ONTO CELLULOSE BY MODIFICATION WITH AMPHIPHILIC COPOLYMER
- High-Mobility p-Channel Metal-Oxide-Semiconductor Field-Effect-Transistor on Strained Si
- CHARACTERISTICS OF CELLULASE MODIFIED WITH A COPOLYMER OF POLYETHYLENE GLYCOL DERIVATIVE AND MALEIC ACID ANHYDRIDE
- Reliability Improvement of Thin Oxide by Double Deposition Process of Silicon Using Chemical Vapor Deposition
- High-Temperature Elactrical Properties of Y_1Ba_2Cu_3O_ : Electrical Properties of Condensed Matter
- Visible Korean Human : Other Serially-Sectioned Images of Entire Body(Japan Iorea Joint Symposium 2005 on Medical Imaging)
- Effect of ZrO_2 Addition to the CaO-SiO_2-MgO-CaF_2 Slags on the Sulfur Removal from the 16Cr-14Ni Stainless Steel Melts
- Induction of Apoptosis by Radix Paeoniae Alba Extract through Cytochrome c Release and the Activations of Caspase-9 and Caspase-3 in HL-60 Cells(Molecular and Cell Biology)
- Phosphate Capacity of CaO-SiO_2-MnO-FeO Slag Saturated with MgO
- Hot Metal Desulfurization by CaO-SiO_2-CaF_2-Na_2O Slag Saturated with MgO
- Rheological Characterization of Suspension and Gel Prepared from Colloidal Silica for Sealed Lead-Acid Batteries by Small Amplitude Dynamic Oscillation Measurement
- Up-Regulation in Receptor for Advanced Glycation End-Products in Inflammatory Circumstances in Bovine Coccygeal Intervertebral Disc Specimens In Vitro
- Thermodynamics of Copper Dissolution into MnO-SiO_2-MnS Inclusion System
- Inhibition of Cytokine-Mediated Nitric Oxide Synthase Expression in Rat Insulinoma Cells by Scoparone(Molecular and Cell Biology)
- A Case of Hypohidrotic Ectodermal Dysplasia
- Thermodynamics of Titanium Oxide in CaO-SiO_2-Al_2O_3-MgO_-CaF_2 Slag Equilibrated with Fe-11mass%Cr Melt
- Discussion on "The Estimation of the Iso-viscosity Lines in Molten CaF_2-CaO-SiO_2 System"
- Electrochemical Method for Controlling the Interfacial Oxygen in Molten Fe with ZrO_2 Based Solid Electrolyte
- Morphologies of Alumina Nano- and Microparticles at the Fe/Al2O3 Interface and the Effects of Reaction Time and Substrate Roughness on Size Distribution
- Structure-Property Correlations of CaO-SiO_2-MnO Slag Derived from Raman Spectroscopy