Solubility of Calcium and Oxygen in Molten Iron Equilibrated with Slag in CaO, Al_2O_3 or CaO-stabilized ZrO_2 Crucible at 1873K

スポンサーリンク

概要

• 論文の詳細を見る

• The solubility of calcium and oxygen in molten iron equilibrated with CaO–Al2O3–ZrO2 molten slag in CaO, Al2O3 or 5.5 mass% CaO-stabilized ZrO2 crucible at 1873 K was measured by means of the slag-metal equilibrium partition method under Ar gas atmosphere. From the results by XRD and the phase diagram of CaO–Al2O3–ZrO2 system, the slag in a CaO crucible was in equilibrium with CaO·ZrO2 and CaO and the slag composition was 57.36 mass% CaO-34.86% Al2O3-7.78% ZrO2. The slag in a Al2O3 crucible was in equilibrium with CaO·2Al2O3 and ZrO2–CaO solid solution (Css) and the slag composition was 27.08 mass% CaO-53.42% Al2O3-19.50% ZrO2. The slag in a CaO-stabilized ZrO2 crucible was in equilibrium with ZrO2–CaO solid solution (Css) and CaO·ZrO2 and the slag composition was 30.38 mass% CaO- 51.56% Al2O3-18.06% ZrO2. The average concentrations of oxygen and calcium in molten iron in equilibrium with slag and compounds were 251 ppm and 3 ppm in a CaO crucible, 33 ppm and 4 ppm in an Al2O3 crucible and 21 ppm and 5 ppm in a CaO-stabilized ZrO2 crucible, respectively. The logarithm of equilibrium constant, logK, for the reaction of CaO(s) = Ca + O is –4.38 and the interaction parameter of eCaO is 31.8. The value is satisfied the thermodynamic phase stability.

• 2011-08-15

著者

• SEKI Ichiro

  Institute for Materials Research, Tohoku University

• Ashino Tetsuya

  Institute For Materials Research Tohoku University

• Tanabe Jun

  Department Of Basic Science Graduate School Of Arts And Sciences The University Of Tokyo

• Seki Ichiro

  Institute For Materials Research Tohoku University

• Seki Ichiro

  Department Of Chemistry And Materials Science Faculty Of Engineering Tokyo Institute Of Technology

• Nagata Kazuhiro

  Dep. Of Chemistry And Materials Sci. Tokyo Inst. Of Technol.

• Ashino Tetsuya

  Institute For Material Research Tohoku University

• Tanabe Jun

  Department Of Mechanical Engineering Faculty Of Engineering Nippon Institute Of Technology

• Nagata Kazuhiro

  Department Of Cell Biology Chest Disease Research Institute Kyoto University

• NAGATA Kazuhiro

  Department of Conservation Science, Tokyo University of the Arts

• Tanabe Jun

  Department of Applied Chemistry, Faculty of Engineering, Saitama University

関連論文

• Enhanced Tensile Strength and Plasticity of Zr-Cu-Al Bulk Glassy Alloys at Cryogenic Temperatures
• The Oxygen Partial Pressure on the Surface of Na_2O-SiO_2 Molten Glass Heated by Thermal Plasma of Ar
• Excess Vaporization of Na from Na_2O-SiO_2 Molten Slag by Transfer Thermal Plasma of Ar
• PJ-482 Isolated Ischemia at the Conus Branch Artery Causing Proarrhythmic ECG Conversion in Patients with the ECG Pattern of Brugada Syndrome(ECG/Body surface potential mapping/Holter(06)(A),Poster Session(Japanese),The 72nd Annual Scientific Meeting of t
• Chemical Form of Precipitate by Coprecipitation with Palladium for Separation of Trace Elements in High-Purity Metals
• Determination of Trace Element Quantities in Ultra High-Purity Iron by Spectrochemical Analysis after Chemical Separation
• Determination of Trace Amounts of Sulfur in High-Purity Iron by Infrared Absorption after Combustion: Removal of Sulfur Blank
• Expression and Phosphorylation of BiP/GRP78, a Molecular Chaperone in the Endoplasmic Reticulum, during the Differentiation of a Mouse Myeloblastic Cell Line
• Mechanisms of Carburization and Melting of Iron by CO Gas
• Mechanism of Carburizing Followed by Melting of Iron by CO Gas
• Annealing-Induced Devitrification Behavior of a Ti_Zr_Ni_Cu_ Glassy Alloy
• Preparation of a Wide Zr_Al_Ni_5Cu_ Metallic Glass Sheet by a Twin-Roller Type Casting Method and Its Mechanical Properties
• HSP47, a Collagen-Specific Molecular Chaperone, Delays the Secretion of Type III Procollagen Transfected in Human Embryonic Kidney Cell Line 293 : A Possible Role for HSP47 in Collagen Modification
• Does Helicobacter pylori eradication depend on the period of amoxicillin treatment? A retrospective study
• Cerebral Circulation and Metabolism Induced Hypoxemia Especially Its Influence on Cerebral Carbohydrate Metabolism : PROCEEDINGS OF THE 25TH ANNUAL MEETlNG, JAPANESE CIRCULATION SOCIETY Part III
• A Study of Cerebral Circulation by Eyeground Photography during 10% Oxygen Respiration : PROCEEDINGS OF THE 25TH ANNUAL MEETlNG, JAPANESE CIRCULATION SOCIETY Part III
• Clinical Incidence of Arrhythmia : PROCEEDINGS OF THE 25TH ANNUAL MEETlNG, JAPANESE CIRCULATION SOCIETY Part III
• Effect of Na_2O on Crystallization of Mould Fluxes for Continuous Casting of Steel
• Coordination Environment of Fluorine in the CaO-SiO_2-CaF_2 Glasses Bearing Na_2O : A Solid-state ^F MAS NMR Study
• Fluorescently Labeled Proteins as a Tool for Analyzing the Dynamics of Protein Quality Control in Living Cells
• Stability of Cuspidine (3CaO・2SiO_2・CaF_2) and Phase Relations in the CaO-SiO_2-CaF_2 System
• SUCCESSFUL ENDOSCOPIC HEMOSTASIS OF RECTAL DIEULAFOY'S ULCER BY CLIPPING : AGING MAY BE A FACTOR
• Mechanisms of Pig-iron Making from Magnetite Ore Pellets Containing Coal at Low Temperature
• The Formation Mechanism of Ca_2Fe_2O_5 from FeO and CaO
• Measurement of Normal Spectral Emissivity of Liquid Copper
• Concept of Furnace for Metal Refining by Microwave Heating : A Design of Microwave Smelting Furnace with Low CO_2 Emission
• 小児の気縦隔に続発する硬膜外気腫 : 稀な合併症か?
• The change of HSP47, collagen specific molecular chaperone, expression in rat skeletal muscle may regulate collagen production with gravitational conditions
• Magnetic Resonance in an Amorphous Slag:8CaO・8SiO_2・3Fe_2O_3・2FeO
• Quantitative Evaluation of Calcium Phosphate on Surface of Titanium by X-ray Fluorescence Analysis
• Calcium-Phosphate Formation on Titanium Modified with Newly Developed Calcium-Hydroxide-Slurry Treatment
• Relationship between the Aluminum and Oxygen and Sulfur Partitions for Molten Iron and a CaO-Al_2O_3-ZrO_2 Slag in Equilibrium
• The Rapid Diagnosis of Group A Streptococcal Infection : THE 10th CONFERENCE ON THE 10th CONFERENCE ON PREVENTION FOR RHEUMATIC FEVER AND RHEUMATIC HEART DISEASE
• Lattice Constant of Iron and Austenite Including Its Supersaturation Phase of Carbon
• Shift of the Absorption Edge for the Charge Transfer Band in Slags Containing Iron Oxides
• Production of Pig Iron from Magnetite Ore-Coal Composite Pellets by Microwave Heating
• Supersaturation of Carbon in Austenite during Carburization by CO Gas
• Negative C-reactive protein in children with bacterial infection
• Another observation of microphthalmia in an XX male: microphthalmia with linear skin defects syndrome without linear skin lesions
• Brain MR findings in a patient with merosin-negative congenital muscular dystrophy
• Microwave Induced Solid-Solid Reactions between Fe_3O_4 and Carbon Black Powders
• Polycrystalline Wustite Surface Observed by STM and LEED
• Mechanism of Heat Transfer Reduction by Crystallization of Mold Flux for Continuous Casting
• Effect of NaF Addition to Mold Flux on Cuspidine Primary Field
• Crystallization of CaO-SiO_2-TiO_2 Slag as a Candidate for Fluorine Free Mold Flux
• Crystallization and embrittlement behavior of a Zr55Al10Ni5Cu30 metallic glass having different Si and O contents
• Localized Heating and Reduction of Magnetite Ore with Coal in Composite Pellets Using Microwave Irradiation
• A Single-Chain Fv Fragment 2A3 Specific for Native Lysozyme : Isolation from a Human Synthetic Phage Display Antibody Library and Characterization
• Vasomotor abnormality in the brachial and coronary arteries of patients with vasospastic angina or syndrome X
• Trace Analysis of Released Metallic Ions in Static Immersion Test for Characterization of Metallic Biomaterials
• The Floating Potential on the Surface of 25mol%Na_2O-SiO_2 Glass Heated by Thermal Plasma of Ar
• Reduction Kinetics of Hematite Powder Mechanically Milled with Graphite
• Thermal Stability and Mechanical Properties of Ti_Cu_Zr_TM_(TM = Co, Fe) Metallic Glass Sheets Prepared by Twin-Roller Casting Method
• Enhancement of Secretion of Human Procollagen I in Mouse HSP47-Expressing Insect Cells
• Charge Transfer Assisted Ferromagnetic Coupling Observed in an Ion-Radical Salt of a Cross-Cyclophane TTF-Based Donor
• Three-Dimensional Sulfur-Based π-Donor: A Novel Dimeric TTF Derivative of a Cross-Cyclophane Type
• Constrictive Pericarditis with Atrial Septal Defect in Children
• Magnetism and Magnetic Interaction in a Complex Oxide Glass System Containing Deposited Clusters of Magnetite at the Superparamagnetic State
• Determination of Gibbs Energy of Formation of Cuspidine (3CaO・2SiO_2・CaF_2) by Transpiration Method
• A Dynamic Change be ^I-15-(p-Iodophenyl)-3-R, S-Methyl pentadecanoic Acid Myocardial Single Photon Emission Computed Tomography in a 55-Year-Old Woman
• Influence of Precipitation Behavior of Different Crystalline Phases for Embrittlement Behavior of Several Zr-Based Metallic Glasses
• Comparative Measurement of Gas Temperature in a Graphite Atomizer by a Two-line Method of Iron and Nickel Spectral Lines in Graphite Furnace Atomic Absorption Spectrometry
• Degradation Process of Graphite Furnace Estimated from the Atomic Gas Temperature of Iron in Graphite Furnace Atomic Absorption Spectrometry
• Role of a Binary Metallic Modifier in the Determination of Cadmium in Graphite Furnace Atomic Absorption Spectrometry
• Temporal Variation in Gas Temperature at the Atomization Stage in Several Types of Graphite Furnaces for Atomic Absorption Spectrometry
• Temporal Variations in Gas Temperature in an Atomization Stage of Cadmium and Tellurium Evaluated by Using the Two-line Method in Graphite Furnace Atomic Absorption Spectrometry
• Electrostatic Cell-to-Cell Adhesion by a Non-Proteolytic Componet in a Protease Preparation
• Suppression of Crystallization in Ti-Based Alloys by Fluxing
• Complex Permittivity and Permeability of α-Fe_2O_3 and Fe_O Powders in the Microwave Frequency Range between 0.2 and 13.5GHz
• Complex Permittivity and Permeability of SiO_2 and Fe_3O_4 Powders in Microwave Frequency Range between 0.2 and 13.5GHz
• Selectivity of Microwave Energy Consumption in the Reduction of Fe_3O_4 with Carbon Black in Mixed Powder
• Development of a Nitrogen Atmosphere Pretreatment Chamber for the Determination of Trace Amounts of Carbon in High-Purity Iron by the Infrared Absorption Method after Combustion in an Electric Resistance Furnace
• Determination of Trace Amounts of Carbon in High-Purity Iron by Infrared Absorption after Combustion: Pretreatment of Reaction Accelerator and Ceramic Crucible
• Determination of Diffusion Coefficient of Nd^ in NdCrO_3 Based on Solid State Reaction
• Dynamic Deletion of Units for Self-Organizing Map by Introducing a New Measure of Unit's Contribution to Learning (論文特集:自己組織化マップとその応用)
• Nonstoichiometric Wustite (001) Surface Exposing Defect Clusters
• Relation between Viscosity and Thermal Conductivity in Molten Silicate Slags and Fluxes
• New Convenient Dissolution of Iron-Rhodium Alloys Using Hydrochloric Acid Containing a Small Amount of Nitric Acid without Heating for an ICP-AES Analysis
• Roles of collagen fibers and its specific molecular chaperone : analysis using HSP47-knockout mice
• Mechanism and components of endoplasmic reticulum-associated degradation
• Silicon Contamination Adsorbed on Pure Titanium Plate during Soaking Test in Hanks' Balanced Saline Solution
• Regulation and Function of Collagen-specifec Molecular Chaperone, HSP47
• Myocardial Infarction and Left Coronary Ostial Stenosis in Infancy Simulating Anomalous Origin of the Left Coronary Artery : A Case Report
• Excess Electrochemical Vaporization of SiO from Na_2O-SiO_2 Molten Slag by Transfer Thermal Plasma of Ar
• High Temperature Measurement of Complex Permittivity and Permeability of Fe_3O_4 Powders in the Frequency Range of 0.2 to 13.5GHz
• Preface to the Special Issue on "Process Developments of Iron and Steelmaking and Environmental Challenges and New Development in Casting and Solidification"
• Determination of Cadmium in High-Purity Zinc by Electrothermal Atomic Absorption Spectrometry after Coprecipitation with Iron(III) Hydroxide
• Solubility of Calcium and Oxygen in Molten Iron Equilibrated with Slag in CaO, Al_2O_3 or CaO-stabilized ZrO_2 Crucible at 1873K
• Ultrasonic Velocities of Molten Alkali Silicates
• Relaxation Phenomena of Ultrasonic Waves on Molten Alkali Silicates
• Complex Permittivity of Graphite, Carbon Black and Coal Powders in the Ranges of X-band Frequencies (8.2 to 12.4GHz) and between 1 and 10GHz
• Lipoma of the heart in a child clinical, echocardiographic, angiographic, and pathological features.:Clinical, Echocardiographic, Angiographic, and Pathological Features
• Properties of magnesium oxides prepared from various salts and their catalytic activity in 1-butene isomerization.
• Relaxation Phenomena of Ultrasonic Waves on Molten Alkali Silicates
• Smelting of Metallic Titanium from an Oxide Flux Using a CaO-Stabilized ZrO2 Solid-Electrolyte Electrode
• HSP47, a Collagen-Specific Molecular Chaperone, Delays the Secretion of Type III Procollagen Transfected in Human Embryonic Kidney Cell Line 293: A Possible Role for HSP47 in Collagen Modification.

もっと見る 閉じる

スポンサーリンク