Simultaneous Desulfurization and Deoxidation of Molten Steel with in Situ Produced Magnesium Vapor
スポンサーリンク
概要
- 論文の詳細を見る
A new simultaneous desulfurization and deoxidation process of molten steel with magnesium vapor produced in situ by aluminothermic reduction of magnesium oxide is proposed. The pellets composed of MgO and Al are charged into an immersion tube and the magnesium vapor produced in situ by aluminothermic reduction of magnesium oxide is injected directly into molten steel to react with the dissolved sulfur and oxygen in it. Effects of various operating parameters on desulfurization and deoxidation are discussed.In the case of the high initial oxygen concentration, deoxidation of molten steel proceeds preferentially, and desulfurization does not take place. When the oxygen concentration in the melt is low enough, desulfurization of molten steel with magnesium vapor can proceed.A higher initial sulfur concentration increases the desufurization ratio of molten steel. The sulfur concentration in the melt tends to be in equilibrium with the magnesium partial pressure in the Mg–Ar bubble rather than the dissolved magnesium concentration in the melt. Increasing pellet mass promoted desulfurization of molten steel. The maximum desulfurization ratio of molten steel can be obtained at a relatively low argon carrier gas flow rate. In both cases of the porous magnesia and the dense alumina immersion tubes with injecting holes, addition of lime onto the melt surface increases the desulfurization ratio. The desulfurization using the dense alumina tube is accompanied by resulfurization more significantly at the later stage than that using the porous magnesia tube.
- 社団法人 日本鉄鋼協会の論文
- 2007-03-15
著者
-
Yang Jian
Department of Electronic Engineering, Tsinghua University
-
Yang J
Department Of Materials Physics And Energy Engineering Graduate School Of Engineering Nagoya Univers
-
Yang J
Tsinghua Univ. Beijing Chn
-
Yang Jian
Nagoya Univ. Nagoya Jpn
-
Kuwabara Mamoru
Department of Materials, Physics and Energy Engineering, Gradurate School of Engineering, Nagoya Uni
-
Yang Jian
Department Of Materials Physics And Energy Engineering Graduate School Of Engineering Nagoya Univers
-
Kuwabara Mamoru
Dept. of Materials, Physics and Energy Eng. Nagoya Univ.
-
LIU Zhongzhu
Graduate School of Engineering, Nagoya University
-
SANO Masamichi
Department of Materials, Physics and Energy Engineering, Graduate School of Engineering, Nagoya Univ
-
LIU Zhongzhu
Department of Materials, Physics and Energy Engineering, Graduate School of Engineering, Nagoya Univ
-
Yang Jian
Graduate School Of Engineering Nagoya University
-
Liu Zhongzhu
Graduate School Of Engineering Nagoya University
-
Sawada Takashi
Department Of Materials Physics And Energy Engineering Graduate School Of Engineering Nagoya Univers
-
Sano Masamichi
Department Of Materials Physics And Energy Engineering Graduate School Of Engineering Nagoya Univers
-
Sano M
School Of Engineering Nagoya University
-
Yang Jian
Department Of Cardiology Renmin Hospital Of Wuhan University
-
Kuwabara Mamoru
Shougang Res. Inst. Of Technol.
-
Kuwabara Mamoru
Department Of Materials Physics And Energy Engineering Graduate School Of Engineering Nagoya Univers
-
Uchida Naoyuki
Nagoya University
-
SAKAI Takao
Department of Materials, Physics and Energy Engineering, Graduate School of Engineering, Nagoya Univ
-
Liu Z
Department Of Materials Physics And Energy Engineering Graduate School Of Engineering Nagoya Univers
-
Sakai Takao
Department Of Electrical Engineering Faculty Of Engineering Musashi Institute Of Technology
-
Yang Jian
Department Of Cardiology Daping Hospital The Third Military Medical University
-
Yang J
Department Of Materials Physics And Energy Engineering Graduate School Of Engineering Nagoya Univers
-
Yang Jian
Department Of Anesthesiology University Of Florida College Of Medicine
-
Liu Zhongzhu
Graduate School Of Engineering Nagoya Univ.
関連論文
- Inhibitory effect of ETB receptor on Na^+-K^+ ATPase activity by extracellular Ca^ entry and Ca^ release from the endoplasmic reticulum in renal proximal tubule cells
- TK-2-3 A New Approach to Ship Detection in a Polarimetric SAR Image
- TK-2-3 A New Approach to Ship Detection in a Polarimetric SAR Image
- TK-2-3 A New Approach to Ship Detection in a Polarimetric SAR Image
- TK-2-3 A New Approach to Ship Detection in a Polarimetric SAR Image
- TK-2-3 A New Approach to Ship Detection in a Polarimetric SAR Image
- Characteristics of Inclusions Generated during Al–Mg Complex Deoxidation of Molten Steel
- P3-56 Influence of High Power Ultrasonic Irradiation on Primary Nucleation Process during Solidification(Poster session 3)
- P3-5 Measurement of Temperature Distribution on the Surface of Acoustic Reactor by Use of Thermal Video System(Poster session 3)
- P2-61 Behavior of Microjets Generated in Molten Metal(Poster session 2)
- P2-34 Acoustic Cavitation Based Production of Foamed Metallic Material(Short oral presentation for posters)
- P2-33 Characteristics of High Frequency Sound Irradiated from Electromagnetically Driven Plate(Short oral presentation for posters)
- Visualization of Acoustically Induced Cavitation Bubbles and Microjets with the Aid of a High-Speed Camera
- P2-65 Development and Evaluation of Electromagnetically Driven Wideband Ultrasonic Oscillator(Short presentation for poster)
- P2-64 Visualization of Acoustically Induced Cavitation Bubbles and Microjets with the Aid of High Speed Camera(Short presentation for poster)
- Acoustic Cavitation-based Processing of Materials
- Effect of Initial Oxygen Concentration on the Rate of SiO_2 Inclusion Removal from Molten Cu
- Rate of SiO_2 Inclusion Removal from Molten Cu to Slag under Gas Injection Stirring Condition
- Rate of SiO_2 Inclusion Removal from Molten Cu to Slag under Mechanical Stirring Condition
- Unsupervised Polarimetric SAR Image Classification(Sensing)
- Using Similarity Parameters for Supervised Polarimetric SAR Image Classification (Regular section)
- Effects of Carbon and/or Alkaline Earth Elements on Grain Refinement and Tensile Strength of AZ31 Alloy
- Effects of Manganese and/or Carbon on the Grain Refinement of Mg-3Al Alloy
- The Effect of Magnesium Gas Injecting Conditions on the Rate of Hot Metal Desulfurization
- Effect of Nano-Scale Copper Sulfide Precipitation on Mechanical Properties and Microstructure of Rapidly Solidified Steel with Tramp Copper Element
- Kinetics of Isothermal Reduction of MgO with Al
- "In-situ" Observation of the δ/γ Phase Transformation on the Surface of Low Carbon Steel Containing Phosphorus at Various Cooling Rates
- Morphology Control of Copper Sulfide in Strip Casting of Low Carbon Steel
- In Situ Observation of Aluminothermic Reduction of MgO with High Temperature Optical Microscope
- Prevention of Resulfurization in Desulfurization Process with Magnesium Vapor Produced in Situ by Aluminothermic Reduction of Magnesium Oxide
- Mechanism of Resulfurization in Magnesium Desulfurization Process of Molten Iron
- Improvement on Desulfurization Efficiency of Molten Iron with Magnesium Vapor Produced In-situ by Aluminothermic Reduction of Magnesium Oxide
- Behavior of Magnesium in the Desulfurization Process of Molten Iron with Magnesium Vapor Produced In-situ by Aluminothermic Reduction of Magnesium Oxide
- Effects of Operating Parameters on Desulfurization of Molten Iron with Magnesium Vaper Produced In-situ by Aluminothermic Reduction of Magnesium Oxide
- Desulfurization of Molten Iron with Magnesium Vapor Produced In-situ by Aluminothermic Reduction of Magnesium Oxide
- Desulfurization of Molten Iron with Magnesium Vapor Produced In-situ by Carbothermic Reduction of Magnesium Oxide
- Classification of Terrain by Implementing the Correlation Coefficient in the Circular Polarization Basis Using X-Band POLSAR Data
- New Formula of the Polarization Entropy (Sensing)
- Distribution of the Received Voltage's Phases in the Cross-Polarized Channel Case
- The Periodicity of the Scattering Matrix and Its Application
- Compound Scattering Matrix of Targets Aligned in the Range Direction
- Optimal Problem for Contrast Enhancement in Polarimetric Radar Remote Sensing
- Stable Decomposition of Mueller Matrix
- The Formulae of the Characteristic Polarization States in the Co-Pol Channel and the Optimal Polarization State for Contrast Enhancement
- Prospect for Innovative Steelmaking Process in the Forthcoming Century
- Nucleation of Acicular Ferrite on Sulfide Inclusion during Rapid Solidification of Low Carbon Steel
- Interaction between Phosphorus Micro-Segregation and Sulfide Precipitation in Rapidly Solidified Steel-Utilization of Impurity Elements in Scrap Steel
- Effect of Phosphorus on Sulfide Precipitation in Strip Casting Low Carbon Steel
- Crystallography and Precipitation Kinetics of Copper Sulfide in Strip Casting Low Carbon Steel
- Precipitation of Copper Sulfides and their Effects on Mechanical Properties in Strip Casting Low Carbon Steel
- Effect of Nano-Scale Copper Sulfide Particles on the Yield Strength and Work Hardening Ability in Strip Casting Low Carbon Steel
- Urotensin II Induces Migration of Endothelial Progenitor Cells via Activation of the RhoA/Rho Kinase Pathway
- Stable Decomposition of Mueller Matrix
- Relationship between a Standing-Wave Field and a Sonoluminescing Field
- Full Band Gap in Fcc and Bcc Photonic Band Gaps Structure : Non-Spherical Atom
- Solvotermal Preparation of Silver Chalcogenides Ag_2E (E=S,Se,Te)
- A New Solvothermal-Reduction Pathway to Nanocrystalline MTe(M=Zn, Pb)
- Simultaneous Desulfurization and Deoxidation of Molten Steel with in Situ Produced Magnesium Vapor
- Unsupervised Classification of Polarimetric SAR Images by EM Algorithm(Sensing)
- Effect of Iron and/or Carbon on the Grain Refinement of Mg-3Al Alloy
- Effect of Lime Particle Size on Melting Behavior of Lime-containing Flux
- A-4-1 A PRE-TEST APPROACH FOR SPECKLE FILTERING IN POLARIMETRIC SAR DATA
- Mechanism of Carbothermic Reduction of Hematite in Hematite-Carbon Composite Pellets
- A Super-Resolution Time Delay Estimation Based on the MUSIC-Type Algorithm(Regular section)
- One-Dimensional PbS/Polymer Nanocomposite of Core/Sheath Structure Fabricated by Hydrothermal Polymerization and Simultaneous Sulfidation
- Effect of Process Parameters on Ultrasonic Separation of Dispersed Particles in Liquid
- Gas Injection from Slot Nozzles with Various Shapes in Water
- Mechanism of Carbothermic Reduction of Chromium Oxide
- Suppression of Slag Foaming under Sound Wave Application
- Control of Foam Height by Using Sound Waves
- Bubble Behaviour and Absorption Rate in Gas Injection through Rotary Lances
- Mixing Characteristics under Gas Injection through Rotary Lance Submerged in Liquid Bath
- cAMP-Response-Element-Binding-Protein-Binding Protein Silencing Inhibits Thrombin-Induced Endothelial Progenitor Cell Migration via Downregulation of CXCR4 Expression
- Nucleation and Growth of Alumina Inclusion in Early Stages of Deoxidation : Numerical Modeling
- Effect of Sn on Microstructure and Sulfide Precipitation in Ultra Low Carbon Steel
- Reduction of Iron Oxide in Sulfur Bearing Slag by Graphite
- Isothermal Precipitation Behavior of Copper Sulfide in Ultra Low Carbon Steel
- Characteristics of Inclusions Generated during Al-Mg Complex Deoxidation of Molten Steel
- Behavior of Inclusions in Deoxidation Process of Molten Steel with in Situ Produced Mg Vapor
- Gas Dispersion Phenomena and Mixing Characteristics under Gas Injection through Slot Nozzle Submerged in Water
- Bubble Behavior and Heat Transfer in Preheated Gas Injection into Liquid Bath
- High Power Ultrasonics in Pyrometallurgy : Current Status and Recent Development
- Analysis of Pyroelectricity of Poly (vinylidene fluoride) by Residual Charge Measuring Technique
- Orientation of Fibers in Liquid by Ultrasonic Standing Waves
- A Binary Tree Structured Terrain Classifier for Pol-SAR Images
- Misplacement of LVAD inflow cannula leads to insufficient output and tissue hypoperfusion
- Role of Gα_- and Gα_-protein subunit linkage of D_3 dopamine receptors in the natriuretic effect of D_3 dopamine receptor in kidney
- A functional epidermal growth factor (EGF) polymorphism, EGF serum levels and renal cell carcinoma risk in a Chinese population
- D_3 dopamine receptor regulation of D_5 receptor expression and function in renal proximal tubule cells
- Gelsenicine from Gelsemium elegans Attenuates Neuropathic and Inflammatory Pain in Mice
- Influence of High-Power Ultrasonic Irradiation on Primary Nucleation Process during Solidification
- An Improved Generalized Optimization of Polarimetric Contrast Enhancement and Its Application to Ship Detection
- Acoustic-Cavitation-Based Production of Foamed Metallic Material
- High Power Ultrasonics in Pyrometallurgy: Current Status and Recent Development
- Effect of Slag Foaming on the Reduction of Iron Oxide in Molten Slag by Graphite.
- Mixing Phenomena in a Liquid Bath Stirred by Gas Jets through Side and Inclined Nozzles.
- Effect of Slag Composition on the Kinetics of the Reduction of Iron Oxide in Molten Slag by Graphite.
- Kinetics of carbon oxidation reaction between molten iron of high carbon concentration and iron oxide containing slag.
- Robust Sensor Registration with the Presence of Misassociations and Ill Conditioning