Effects of Process Parameters and Substrate Structures on Growth of Single-Walled Carbon Nanotubes by Catalytic Decomposition of Ethanol
スポンサーリンク
概要
- 論文の詳細を見る
Single-walled carbon nanotubes (SWNTs) were prepared by ethanol chemical vapor deposition (CVD), using Co and Mo as metal catalysts deposited on Si/SiO2 substrates with and without an Al underlayer. The effects of Mo addition, catalyst particle size and the Al underlayer were discussed on the basis of the results of scanning electron microscopy (SEM), atomic force microscopy (AFM) and Raman measurement. In substrates with Si/SiO2/Co/Mo structures, a Co layer with a thickness of 1 nm produced smaller catalyst particles and SWNTs with a thinner diameter and at a higher yield than a Co layer with a thickness of 2 nm. The addition of Mo to Co films in substrates was shown to have the effect of suppressing Co aggregation and keeping catalyst particles small, even with high-temperature CVD growth. It was also found that the introduction of an Al underlayer promoted SWNT growth because of the formation of Al2O3 clusters after heat treatment.
- Published by the Japan Society of Applied Physics through the Institute of Pure and Applied Physicsの論文
- 2006-08-15
著者
-
Saito Yahachi
Department Of Applied Physics Faculty Of Engineering Nagoya University
-
Zhao Yanli
Department of Quantum Engineering, Nagoya University, Furo-cho, Chikusa-ku, Nagoya 464-8603, Japan
-
Seko Kazuyuki
Department of Quantum Engineering, Nagoya University, Furo-cho, Chikusa-ku, Nagoya 464-8603, Japan
関連論文
- High Resolution CNT-FED and Improvement in Field-Emission Characteristics
- Field Ion-Scanning Tunneling Microscopy Study of C_60 on the Si(100) Surface
- Study on Phase Transition of C_ through Fourier-Transform Infrared Spectroscopic Measurements
- Electron Emission Sites on Carbon Nanotubes and the Energy Spectra : Surfaces, Interfaces, and Films
- Synthesis, Crystal Structure and Magnetic Properties of Iron Particles Encaged in Carbon Nanocapsules
- Stabilization Mechanism of Liquid-Lithium Cones during Field Electron Emission
- -Oriented Tungsten Field Emitter Coated with Liquid Lithium Thin Film
- A New Emission Spectrum of Au_2 in the Gas Evaporation Technique: 761-809 nm
- Field Emission Patterns from Single-Walled Carbon Nanotubes
- Magnetic Properties of Iron in Nanocapsules
- Synthesis and Reactions of Organoplatinum Compunds C_, C_Pt_n
- Facile Cleavage of Carbon-Palladium Bonds in C_Pd_n with Phosphines and Phosphites. An Alternative Route to (η^2-C_)PdL_2 and Discovery of Fluxionarity Suggesting the Rotation of C_ on the PdL_2 Species in Solution
- Single-Wall Carbon Nanotubes Growing Radially from Ni Fine Particles Formed by Arc Evaporation
- Synthesis of Sc_C_ Crystallites Encapsulated in Carbon Nanocapsules by Arc Evaporation of Sc-C Composite
- LaC_2 Encapsulated in Graphite Nano-Particle
- Relation between peak structures of loss functions of single double-walled carbon nanotubes and interband transition energies
- Field Emission Patterns Originating from Pentagons at the Tip of a Carbon Nanotube
- Magic Numbers in a Mass Spectrum of Lithium Clusters Emitted from a Liquid Metal Ion Source
- Magic Numbers and Critical sizes of Tin Clusters Emitted from a Liquid Metal Ion Source
- X-Ray Emission Spectrum of Solid C_
- Emission Enhancement by Excimer Laser Irradiation over a Weblike Carbon Nanotube Layer
- Bulk Plasmons in Solid C_
- Cathode Ray Tube Lighting Elements with Carbon Nanotube Field Emitters
- Formation of Ultrafine Metal Particles by Gas-Evaporation : VI. Bcc Metals, Fe, V, Nb, Ta, Cr, Mo and W
- Multiply-Twinned Particles of Germanium("Formation of Ultrafine Praticls by Gas-Evaporation Technique.V")
- Formation of Ultrafine Particles by Gas-Evaporation Technique. : V.Silicon and Germanium in Argon
- Crystal Structure of C_ under High Pressure : Effect of Alloying
- Magnetic Susceptibility and X-Ray Diffraction Studies on the Growth and Disappearance Processes of the Superconducting Phase in C_K_x
- Threshold Behavior of Synchrotron Radiation Photoionization for Bi_n (n≦4)
- Thermal Study of a Silylmethylated Fullerene Leading to Preparation of Its Vacuum Deposited Thin Films
- Electron energy-loss spectroscopy study of the electronic structure of boron nitride nanotubes
- Structures of Boron Nitride Nanotubes with Single-Layer and Multilayers Produced by Arc Discharge
- Scanning Tunneling Microscopy of C_ on the Si(111)7 × 7 Surface
- Isolated High-Purity Platinum Nanowire Growth via Field Emission from a Multi-Walled Carbon Nanotube
- Formation of Carbon Nanotubes by Evaporation of Carbon Rod Containing Scandium Oxide
- Catalytic Hydrogenation of Olefins and Acetylenes over C_Pd_n
- Two-Dimensional Patterson Synthesis of Al-Mn Quasicrystal by Optical Method
- Encapsulation of ZrC and V_4C_3 in Graphite Nanoballs via Arc Burning of Metal Carbides/Graphite Composites
- Rate Correlation of Photoinduced Electron Transfer to C_
- Field Emission of Electrons from Graphitic Nanofibers Produced in a Hydrogen Arc Discharge
- Structure and Morphology of Solid C_/C_ and C_ Grown from Benzene Solution
- Carbon K-Shell X-Ray Absorption Near-Edge Structure of Solid C_
- Crystal Structure of Buckminsterfullerene (C_) Incorporated by a U-Shaped Twin Donor
- Effect of Cathode–Anode Distance on Field Emission Properties for Carbon Nanotube Film Emitters
- Emission Spectra of Cu_2, Ag_2 and Au_2 in Gas Evaporation
- Exciton Effects Optical Transitions in Single-Wall Carbon Nanotubes
- Electron Energy Loss Spectrum Near Carbon K-Edge in Solid C_
- Crystallographic Structure and Magnetic Properties of Co Fine Particles Encaged in Carbon Nanocapsules
- In situ Transmission Electron Microscopy of Field-Emitting Bundles of Double-Wall Carbon Nanotubes
- Formation of Secondary Thin Carbon Nanotubes on Thick Ones and Improvement in Field-Emission Uniformity
- Electron Energy-Loss Spectra of Single-Shell Carbon Nanotubes
- High-Resolution Electron Energy-Loss Spectra of Solid C_
- Carbonization of Si(111)-$7\times 7$ Surface Using CH4 with Hot Tungsten Filament
- Evolution of Field Electron Emission Pattern from Multilayered Graphene Induced by Structural Change of Edge
- Optical Emission Studies on Chemical Species in an Arc Flame of Fullerene/Metallofullerene Generator
- Nanoactuation of Telescoping Multiwalled Carbon Nanotubes inside Transmission Electron Microscope
- Effects of Process Parameters and Substrate Structures on Growth of Single-Walled Carbon Nanotubes by Catalytic Decomposition of Ethanol
- Formation of Quasicrystalline Aluminium-Vanadium and Aluminium-Chromium Fine Particles by Gas-Evaporation Technique