Molecular dynamics analysis of the effect of F on the structure of molten Na_2O-NaF-Al_2O_3-SiO_2 system

スポンサーリンク

概要

• 論文の詳細を見る

• For the molten quaternary Na2O-NaF-SiO2-Al2O3 system at 1 673 K, the effect of F ion on the distribution of Si and Al tetrahedral complex anions, and the relationship between the Si and Al tetrahedra has been investigated by applying molecular dynamics simulation. In the calculation, SiO2 and Al2O3 contents in the melts were all fixed to 50.0 and 16.6 mol% respectively and only the ratio of Na2O/Na2F2 was changed. It was found that NaF in the aluminosilicate melts was able to work as a network modifier for Al tetrahedra linkages but not for Si ones. Namely, F can break the linkage between Al tetrahedra and coordinate to Al tetrahedra. The replacement of nonbridging oxygen in Si tetrahedra by F ions was possible since the calculated results showed the existence of a small amount of F coordinated to Si tetrahedra.

• 社団法人日本鉄鋼協会の論文

著者

• Sasaki Yasushi

  Graduate Institute of Ferrous Technology (GIFT), Pohang University of Science and Technology (POSTEC

• Sasaki Yasushi

  Graduate Inst. Of Ferrous Technol. (gift) Pohang Univ. Of Sci. And Technol. (postech)

• ISHII Kuniyoshi

  Graduate School of Engineering, Hokkaido University

• Ishii Kuniyoshi

  Graduate School Of Engineering Hokkaido University

• Sasaki Yasushi

  Graduate School Of Engineering Hokkaido University

関連論文

• Formation of Calcium Ferrites under Controlled Oxygen Potentials at 1273 K
• Bubble Formation Frequency at a Single-hole Nozzle Immersed in a Mercury Bath
• Prediction of the Occurrence of Swirling Liquid Jet Generated by Off-centered Nozzle
• The Coordination of F Ions around Mg and Ca Ions in Molten CaO–CaF2–MgO–SiO2 System at 1873K
• EFFECT OF LOW-DENSITY PARTICLES ON SWIRLING LIQUID JET IN TRANSIENT PERIOD
• The Coordination of F Ions around Al and Ca Ions in Molten Aluminosilicate Systems
• The Role of Ca and Na Ions in the Effect of F Ion on Silicate Polymerization in Molten Silicate System
• The Estimation of the Iso-viscosity Lines in Molten CaF2–CaO–SiO2 System
• Occurrence Condition of a Swirling Bubbling Jet in a Water Bath Covered with an Oil Layer
• Stress Relaxation Behavior with Molten CaO-SiO_2-Al_2O_3 Slag
• The Effect of Grain Boundaries on the Surface Rearrangement during Wustite Reduction within its Range of Existence
• Measuring Strains for Hematite Phase in Sinter by Electron Backscattering Diffraction Method
• The Effect of Grain Boundaries on Iron Nucleation during Wustite Reduction Process
• Rupture Phenomena of Molten Alkali Silicate Thin Films
• Rupture phenomena of molten alkali silicate thinfilms
• The Role of Molten Slag in Iron Melting Process for the Direct Contact Carburization: Wetting and Separation
• Simulation of Effect of Pore Structure on Coke Strength Using 3-dimensional Discrete Element Method
• Reply to “Discussion on the Estimation of the Iso-viscosity Lines in Molten CaF2–CaO–SiO2 System”
• The Surface Structure Correlation with the Wustite Surface Rearrangement
• The Effect of Grain Boundary on the Wustite Reduction Process
• The Surface Structure Correlations with the Iron Nucleation in the Wustite Reduction
• The Surface Structure Correlations with Wustite Reduction Mechanism
• Carbonation Reaction of CaO in Jet Milling of CO2 Gas
• The Role of Iron Oxide Bearing Molten Slag in Iron Melting Process for the Direct Contact Carburization
• Effect of Initial Acceleration History on Transition to Turbulence in Pipe Flow
• Empirical Equations for Bubble Formation Frequency from Downward-Facing Nozzle with and without Rotating Flow Effects
• Raman Spectroscopic Analysis of Molten Na_2O-NaCl-SiO_2 System
• Analysis of the Transition State of the Carbon and Iron Oxide Mixture Activated by Mechanical Milling
• The Coordination of F Ions around Al and Ca Ions in Molten Aluminosilicate Systems
• The Role of Ca and Na Ions in the Effect of F Ion on Silicate Polymerization in Molten Silicate System
• The Estimation of the Iso-viscosity Lines in Molten CaF_2-CaO-SiO_2 System
• Characteristics of Nano-reactor and Phenomena during Mechanical Milling of Hematite-Graphite Mixture
• Gas Evolution during Mechanical Milling of Hematite-Graphite Mixture
• Intensive Improvement of Reduction Rate of Hematite-Graphite Mixture by Mechanical Milling
• Reaction Behavior of Facing Pair Between Hematite and Graphite: A Coupling Phenomenon of Reduction and Gasification
• The Preferable Growth Direction of Iron Nuclei on Wustite Surface during Reduction
• Carburization Degree of Iron Nugget Produced by Rapid Heating of Powdery Iron, Iron Oxide in Slag and Carbon Mixture
• Carburization of Iron by Ar-CO-H_2 at 1523K
• The Effect of the Liquid Fe-C Phase on the Kinetics in the Carburization of Iron by CO at 1523K
• The kinetics of carburization of pure iron in CO-Ar mixtures at 1523K
• Repulsive Capillary Force between two Plates Linked by a Concave Molten Slag Bridge
• Ejection of small sedimentary particles into a cylindrical bath by swirl motion of bubbling jet (特集 流動の可視化)
• Prediction of Argon Gas Attachment to Sliding Gate in Immersion Nozzle
• Forward and Backward Reaction Rate Constants of the Reaction of C+O=CO (g) on Fe-C Melts
• Enhancement of Iron Melting Rate under the Co-existence of Graphite and Wustite
• Molecular dynamics analysis of the effect of F on the structure of molten Na_2O-NaF-Al_2O_3-SiO_2 system
• Molecular Dynamics Analysis of Three-dimensional Anionic Structures of Molten Al_2O_3-Na_2O-SiO_2 System
• In Situ Observation of Diamond Gasification and the Crystallographic Relationship of Graphite Formed on the Surface of Diamond
• Kinetic Analysis of the Gasification of Diamond
• Simulation of Effect of Pore Structure on Coke Strength Using 3-dimensional Discrete Element Method
• The Role of Molten Slag in Iron Melting Process for the Direct Contact Carburization : Wetting and Separation
• Formation of Calcium Ferrites under Controlled Oxygen Potentials at 1273K
• Fabrication of Ultra High Nitrogen Austenitic Stainless Steel by NH_3 Solution Nitriding
• Thermodynamic Analysis on the Dust Generation from EAF for the Recycling of Dust
• Carbonation Reaction of CaO in Jet Milling of CO_2 Gas
• The Role of Iron Oxide Bearing Molten Slag in Iron Melting Process for the Direct Contact Carburization
• The Coordination of F Ions around Mg and Ca Ions in Molten CaO-CaF_2-MgO-SiO_2 System at 1873K
• Preface to the Special Issue on "Innovative Ironmaking Reactions in New BF to Aim at Halving Energy Needs and Minimizing Environmental Load"
• Prediction of the Period of Swirl Motion Appearing in Gas Injection Processes at High Temperatures
• Mixing Time in a Bath in the Presence of Swirl Motion Induced by Horizontal Gas Injection with an L-Shaped Lance
• Effect of Repeatedly Imposed Acceleration on the Transition to Turbulence in Transient Circular Pipe Flow
• Model study of the effect of slag layer on the swirl motion of molten steel jet (環境特集号(その1))
• Grain Refinement of α-iron by Repeated Carburizing and Decarburizing Reactions
• Feasibility of Solid-state Steelmaking from Cast Iron : Decarburization of Rapidly Solidified Cast Iron
• Mixing Time in a Cylindrical Bath Agitated by Gas Injection through an L-shaped Top Lance in the Absence of Swirl Motion

もっと見る 閉じる

スポンサーリンク