Influence of Thermomechanical Parameters on the Competition between Dynamic Recrystallization and Dynamic Strain Induced Transformation in C-Mn and C-Mn-Nb Steels Deformed by Hot Torsion
スポンサーリンク
概要
- 論文の詳細を見る
The thermomechanical parameters have a great influence on the restoration processes of the steels and, consequently, on the grain size and morphology during and after deformation. At higher deformation temperatures the ferritic grain refinement may occur by dynamic recrystallization of austenite (DRX) and at lower temperatures, the operating mechanism might be dynamic strain-induced austenite–ferrite transformation (DSIT). In the present work, the effect of thermomechanical parameters on DSIT was investigated. In this study, after soaking at 1200°C, the samples were cooled to 1100°C submitted to hot torsion deformation to decrease the austenite grain size and then cooled to 900, 850 or 800°C for further hot torsion deformation, at strain rates of 1 s−1 and 5 s−1 and total strains of 1.5, 2.5 and 3.5. The steels were deformed by torsion in a ‘Gleeble’ thermomechanical simulator and water cooled immediately after deformation. In the steel without Nb, recrystallization occurred before enough deformation could be accumulated to induce ferrite formation, so DSIT would only occurred at the lowest temperature investigated, 800°C. In the Nb steel, Nb addition delayed austenite recrystallization allowing DSIT ferrite to form at higher temperatures than the steel without Nb, 850°C. The dynamic recrystallization of austenite at 850°C was retarded by the Nb addition thus allowing the occurrence of DSIT at this temperature. Variations in strain rate and amount of strain did not significantly change the dynamic mechanism of grain refinement, but did change the critical strain to start DRX and DSIT, as well as the fraction of the strain-induced transformed ferrite.
- 社団法人 日本鉄鋼協会の論文
- 2007-11-15
著者
-
De Souza
Departamento De Fisiologia E Biofisica Institute De Biologia Universidade Estadual De Campinas
-
De Souza
Departamento De Ciencia Dos Materiais E Metalurgia Pontificia Universidade Catolica Do Rio De Janeir
-
FERREIRA Jetson
Escola de Engenharia Industrial Metalurgica de Volta Redonda, Universidade Federal Fluminense
-
DE MELO
USIMINAS, Gerencia de Pesquisa e Desenvolvimento
-
SANTOS Dagoberto
Departamento de Engenharia Metalurgica e de Materiais, Escola de Engenharia-Universidade Federal de
-
RIOS Paulo
Escola de Engenharia Industrial Metalurgica de Volta Redonda, Universidade Federal Fluminense
-
Rios Paulo
Universidade Federal Fluminense Escola De Engenharia Industrial Metalurgica De Volta Redonda
-
Rios Paulo
Escola De Engenharia Industrial Metalurgica De Volta Redonda
-
Ferreira Jetson
Escola De Engenharia Industrial Metalurgica De Volta Redonda Universidade Federal Fluminense
-
Santos Dagoberto
Dep. Of Metallurgical And Materials Engineering Federal Univ. Of Minas Gerais
-
De Melo
Usiminas Gerencia De Pesquisa E Desenvolvimento
-
De Souza
Departamento De Bioquimica Instituto De Ciencias Basicas Da Saude Universidade Federal Do Rio Grande
-
De Souza
Departamento De Bioquimica Centro De Ciencias Biologicas (ccb) Universidade Federal De Pernambuco (ufpe)
関連論文
- Detection and Classification of Transient Disturbances in Power Systems
- Effects of Tea from Turnera ulmifolia L. on Mouse Gastric Mucosa Support the Turneraceae as a New Source of Antiulcerogenic Drugs
- Femoral and acetabular revision using impacted nondemineralized freeze-dried bone allografts
- Influence of Thermomechanical Parameters on the Competition between Dynamic Recrystallization and Dynamic Strain Induced Transformation in C-Mn and C-Mn-Nb Steels Deformed by Hot Torsion
- Bilateral extensive cerebral infarction and mesenteric ischemia associated with segmental arterial mediolysis in two young women
- Mechanical Behavior and Microstructure of High Carbon Si-Mn-Cr Steel with Trip Effect
- Thalidomide Analogs from Diamines : Synthesis and Evaluation as Inhibitors of TNF-α Production
- Predicting Outcome in Acute Low Back Pain Using Different Models of Patient Profiling
- Early Intervention for the Management of Acute Low Back Pain : A Single-Blind Randomized Controlled Trial Biopsychosocial Education, Manual Therapy, and Exercise
- Effects of hyperbaric oxygen on Leishmania amazonensis promastigotes and amastigotes
- Electrochemical Method to Characterize the Chromate Layer on a Zinc Coated Steel Sheet
- Annealing of Cold-worked Austenitic Stainless Steels
- Kinetics of Strain Aging in Cold Rolled Low Strength Multiphase Steel
- Trans Polyunsaturated Fatty Acid Contents in Brazilian Refined Soybean Oil
- A new process of IgG purification by negative chromatography : Adsorption aspects of human serum proteins onto ω-aminodecyl-agarose
- Purification of human IgG by negative chromatography on ω-aminohexyl-agarose
- Cytomixis in Brassica napus var. oleifera and Brassica campestris var. oleifera (Brassicaceae)
- In vitro effect of quinolinic acid on energy metabolism in brain of young rats
- Genetic polymorphism of MUC7 in individuals with aggressive or chronic periodontitis
- Correlation of c-erbB-2 oncogene and p53 tumor suppressor gene with malignant transformation of hydatidiform mole
- Pathologic complete response with neoadjuvant imatinib for locally advanced pelvic GIST
- Detection of the first lectin with antimicrobial activity present in serum of the Amazonian fish tambaqui Colossoma macropomum
- Increased IgG1, IFN-γ, TNF-α and IL-6 responses to Mycobacterium tuberculosis antigens in patients with Tuberculosis are lower after chemotherapy
- B_1 and B_2 kinin receptor participation in hyperproliferative and inflammatory skin processes in mice