HYDRAULIC CONVEYING OF SOLIDS THROUGH PIPE BENDS
スポンサーリンク
概要
- 論文の詳細を見る
Hydraulic transport of solid materials through pipe bends was investigated experimentally. Four kinds of 90° pipe bends of which the radii of curvature were 0, 12, 24 and 48cm, were made of polyacrylate pipe. The pressure drops were measured over sections of about 5 m, each including a pipe bend. The solid particles used in this experiment were glass beads (0.5-2.0mm diameter) and polystyrene particles (1.0mm diameter). The behavior of particles in pipe bends was found to be very much complicated by the effect of gravitational and centrifugal forces and the secondary flow of fluid. The results of the pressure-drop measurement were as follows, a) The horizontal pipe Bend : In the case of polystyrene particles, even though delivered particle concentration exceeded about 20%, the effect of particle concentration mc on the pressure drop did not appear to be the same as in the case of a straight pipeline. On the other hand, in the case of glass particles the additional pressure drop, which was nearly constant regardless of flow rate, increased with increasing particle concentration except where R=0 and 12cm. Moreover, the additional pressure drop was correlated by the dimensionless term Um2/gR (ρs/ρw-1) and mc. b) The vertical pipe bend : It was found from experiment that both polystyrene and glass particles showed additional pressure drop, which was nearly constant regardless of the flow rate, similar to the case of horizontal pipe bends.
- 公益社団法人 化学工学会の論文
著者
-
Toda Masayuki
Department of Chemistry and Chemical Engineering, Faculty of Engineering, Yamagata University, 4-3-16 Jonan, Yonezawa, Yamagata 992-8510, Japan
-
MAEDA SIRO
Department of Chemical Engineering, Tohoku University
-
Saito Shozaburo
Department of Biochemistry & Engineering, Tohoku University
-
KOMORI NORIO
Department of Chemical Engineering, Tohoku University
関連論文
- Modification of Butter Oil by Extraction with Supercritical Carbon Dioxide(Food & Nutrition)
- SEPARATION AND PURIFICATION OF INDOLE FROM COAL TAR BY SUPERCRITICAL FLUID EXTRACTION
- Changes in Gas Permeability and Permselectivity of Natural Zeolite Disk by Heat TreatmentChanges in Gas Permeability and Permselectivity of Natural Zeolite Disk by Heat TreatmentChanges in Gas Permeability and Permselectivity
- GROWTH RATE OF SILICA PARTICLES FROM AMMONIA-CATALYZED HYDROLYSIS OF TETRAETHYL ORTHOSILICATE
- DIGITAL IMAGE ANALYSIS OF PHASE SEPARATION STRUCTURES IN SPINODAL DECOMPOSITION OF A POLYMER BLEND
- APPLICATION OF REGULAR SOLUTION THEORY TO VAPOR-LIQUID EQUILIBRIA OF CRYOGENIC FLUIDS
- TAUTOMERIZATION OF 2,4-PENTANEDIONE IN SUPERCRITICAL CO_2
- PHASE EQUILIBRIA FOR C02-C2H5OH-H20 SYSTEM
- Electron Spin Resonance Investigations and Compensation Mechanism of Europium-Doped Barium Titanate Ceramics
- Effects of accuracy of equation of state for pure components on prediction of binary vapor-liquid equilibria.
- Measurement of critical temperatures of terpenes.
- Correlation of the binary interaction parameter of the modified generalized BWR equation of state.
- Adsorption equilibria of hydrocarbon gaseous mixtures containing polar components.
- Fractional Extraction of Rice Bran Oil with Supercritical Carbon Dioxide
- Properties of porous anodic aluminum oxide films as membranes.
- A semiempirical equation of state for non-polar and polar substances on the basis of perturbation theory.
- Calculation of high-pressure vapor-liquid equilibria of non-polar asymmetric mixtures with an augmented van der Waals equation of state.
- Application of the perturbation theory to vapor-liquid equilibria of systems containing a polar substance.
- Liquid-liquid equilibria for the system of water, ethanol and 1,1-difluoroethane.
- SIMULATION OF PYROLYSIS OF PARAFFINIC HYDROCARBON BINARY MIXTURES
- Adsorption of light hydrocarbon mixtures on molecular sieving carbon MSC-5A.
- VAPOR-LIQUID EQUILIBRIA AND HENRY''S CON-STANTS FOR TERNARY SYSTEMS CONTAINING HYDROGEN AND LIGHT HYDROCARBONS
- VAPOR-LIQUID EQUILIBRIA OF BINARY AND TERNARY SYSTEMS CONTAINING HYDROGEN AND LIGHT HYDROCARBONS
- The compressibility factors of hydrogen-methane, hydrogen-ethane and hydrogen-propane gaseous mixtures.
- Heat transfer to vertical gas-solid suspension flows.
- Particle Size Distributions Produced by Hydrolysis and Condensation of Tetraethylorthosilicate.
- On the functional form of the equation of state for prediction of mixture critical properties.
- Group contribution model based on the hole theory.
- Calculation of solid-liquid equilibria using the modified BWR equation of state of Lee and Kesler.
- Equation of state based on a group contribution model applicable to vapor and liquid phases and its application to n-alkane systems.
- Phase-separation structure of polymer blend of polystyrene and polyisoprene in the presence of styrene-isoprene diblock copolymer.
- A kinetic study of bulk thermal polymerization of styrene.
- MINIMUM TRANSPORT VELOCITY FOR HORIZONTAL PNEUMATIC CONVEYING
- A verage lamellar domain distance in microphase-sepa-ration structure for the system of polystyrene, polyisoprene and styrene-isoprene diblock copolymer.
- Phase transition and equilibrium.
- MOLECULAR SHAPE FACTORS FOR AMMONIA AND THEIR APPLICATION TO VAPOR-LIQUID EQUILIBRIUM CALCULATIONS
- A two-dimensional model for the secondary flow in an agitated vessel with anchor impeller.
- Measurement of vapor-liquid equilibria at elevated temperatures and pressures using a flow type apparatus.
- Convective heat transfer for highly viscous fluids with variable viscosity in cooling pipes.
- SEPARATION OF META- AND PARA-XYLENE MIXTURE BY DISTILLATION ACCOMPANIED BY CHEMICAL REACTIONS
- Heat transfer between wall and solid-water suspension flow in horizontal pipes.
- Mechanism of heat transfer to pseudoplastic fluids in an agitated tank with helical ribbon impeller.
- Effect of dispersed-phase viscosity on the maximum stable drop size for breakup in turbulent flow.
- VAPOR-LIQUID EQUILIBRIA FOR THE NITROGEN-METHANE-CARBON DIOXIDE SYSTEM
- Effects of geometrical variables of helical ribbon impellers on mixing of highly viscous newtonian liquids.
- Simulation model for the rate of bulk polymerization over the complete course of reaction.
- Simulation for high-conversion pyrolysis of branched alkanes.
- VAPOR-LIQUID EQUILIBRIA FOR THE CARBON DIOXIDE-OXYGEN SYSTEM
- HYDRAULIC CONVEYING OF SOLIDS THROUGH PIPE BENDS
- The effects of viscous and inertial forces on drop breakup in an agitated tank.
- Heat transfer and temperature distributions in an agitated tank equipped with helical ribbon impeller.
- Preparation of a new hydrogel and porous glass composite membrane.
- SALTATION VELOCITY FOR HORIZONTAL PNEUMATIC CONVEYING
- PREDICTION OF INITIAL PRODUCT DISTRIBUTIONS FROM PYROLYSIS OF NORMAL PARAFFINIC HYDROCARBONS
- CORRELATION OF CRITICAL LOCUS FOR BINARY MIXTURES BY THE BWR EQUATION
- Simulation of product distributions from pyrolysis of normal and branched alkane mixtures over a wide range of conversions.
- A SIMULATION MODEL FOR HIGH-CONVERSION PYROLYSIS OF NORMAL PARAFFINIC HYDROCARBONS
- Scale effect on breakup process in liquid-liquid agitated tanks.