Diagnostics of Impulse Line Blockage with Multi-sensing Differential Pressure Transmitter at Air Line

スポンサーリンク

概要

• 論文の詳細を見る

• Differential pressure transmitter with an orifice is widely used as a major field flowmeter. A major drawback of this flowmeter used at operation sites is the blockage of an impulse line, which connects a differential pressure transmitter with an orifice tap. In our previous studies, experiments at a water line showed that the diagnostic method based on the pressure fluctuations in the impulse line can diagnose the blockage in the steady state. In this method, however, there was a possibility of making a wrong diagnosis in the transient state. This paper clarifies the applicable conditions of two diagnostic methods: the diagnostic method based on the pressure fluctuations and the diagnostic method based on the phase difference. In particular, the effectiveness of two diagnostic methods in both steady and transient states is investigated by comparing the experimental results at an air line with those obtained at the water line. Through experimental investigations, the following results are derived: (1) The line pressure change has a harmful effect on the blockage diagnosis with the pressure fluctuations. (2) The diagnostic method based on the phase difference can diagnose the blockage even in the transient state; however, this method cannot diagnose the blockage, where the pressure fluctuations are not transmitted at an air line. Therefore, the method based on phase differences remains to be improved in the future work.

• 一般社団法人 日本機械学会の論文

著者

• Uehara Akira

  Research Institute For Science And Engineering Waseda University

• WAKUI Tetsuya

  Osaka Prefecture University

• MIYAJI Nobuo

  Yokogawa Electric Corporation

• YUUKI Yoshitaka

  Yokogawa Electric Corporation

• HASHIZUME Takumi

  Research Institute for Science & Engineering, Waseda University

• EINO Jyun-ichi

  Research Institute for Science & Engineering, Waseda University

関連論文

• C203 DIAGNOSIS OF THICKNESS IN PIPES AND HEAT EXCHANGER TUBES : A CASE OF STRAIGHT PIPES IN WATER LINE(Erosion)
• Model-Based Performance Monitoring with Dynamic Compensation for Heat Utilization Process in Distributed Energy System
• Diagnostics of Impulse Line Blockage with Multi-Sensing Differential Pressure Transmitter at Oil Line
• Diagnostics of Impulse Line Blockage with Multi-sensing Differential Pressure Transmitter at Air Line

スポンサーリンク