Study of Heat Transfer Phenomena in Quenching of Steel (An Analysis of Cooling Curves Accompanied wth Phase Transformation)
スポンサーリンク
概要
- 論文の詳細を見る
The numerical analysis of unsteady heat conduction during quenching using the apparent heat capacity were investigated in this study. The temperature and the latent heat of phase transformation depend on the instantaneous cooling rate at the point A_1(727℃). The cooling curves accompanying the phase transformation were calculated using an iterative technique of implicit finite difference. These were calculated for two boundary condition cases : (1) the measured temperature of any radius (R 1〜R 3), and (2) the boiling curve. Agreement between the experimental and calculated results of case (1) was found. It was verified that the latent heat obtained by the previous study is useful for the numerical analysis of quenching. The calculated cooling curves for case (2) agreed well with the experimental results.
- 一般社団法人日本機械学会の論文
- 1988-02-15
著者
-
Katayama Kozo
Faculty Of Engineering Shibaura Institute Of Technology
-
Maki Tadasu
Faculty Of Engineering Kanagawa University
-
Tajima Mamoru
Faculty Of Engineering Kanagawa University
関連論文
- Researches on Heat and Mass Transfer by Sublimation of Ice
- Study of Heat Transfer Phenomena in Quenching of Steel : Effects of Boiling Heat Transfer on Cooling Curves and Water Temperature on Hardness of Steel
- A Study on Frost Formation : The Process of Frost Formation involving the Phenomena of Water Permeation and Freezing
- Jet Flames Stabilized by a Counter Air Stream
- Effects of Pilot Injection with a Single Fuel Nozzle on a Direct Injection Diesel Engine
- REALIZATION OF RECOVERABLE ZONE FROM THE STAND POINT OF FLOW LINES
- Study of Heat Transfer Phenomena in Quenching of Steel (An Analysis of Cooling Curves Accompanied wth Phase Transformation)
- Study on Heat Transfer Phenomena in Quenching of Steel : Effect of latent heat of phase transformation
- Heat Conduction of Semiconductors : 1st Report, Researches of the Fundamental Equations and the Boundary Conditions
- A Transient Method of Simultaneous Measurement of Thermal Properties Using a Plane Heat Source
- Transient Comparison Methods of Simultaneous Measurement of Thermal Properties
- A New Method of Simultaneous Measurement of Thermal Properties by Iterative Calculations
- Numerical Methods in Transient Heat Conduction : (2nd Report, Methods Using a Digital Computer)
- Measurement of Thermal Properties of Semiconductor by Utilization of the Peltier Effect
- Numerical Methods in Transient Heat Conduction : (1st Report, Methods Using the Analog Computer)
- Researches on Simultaneous Flow of Heat and Fluid through Porous Media : 1st Report, Fundamental Theories