Interaction between Iron Oxides and Olivine in Magnetite Pellets during Reduction to Wustite at Temperatures of 1000–1300°C

スポンサーリンク

概要

• 論文の詳細を見る

• In this study the magnesium diffusion behaviour was studied in pellets with fine and course olivine, with and without additional fine quartzite (<20 μm) after isothermal reduction at 1000–1300°C. It was found that, by using a fine olivine (<38 μm) the whole magnesium content of the olivine was dissolved evenly in the wustite and in the slag, already at 1000°C, in agreement with the equilibrium tie-lines of the FeO–MgO–SiO2 phase diagram. This lead the liquid slag to precipitate into fayalitic olivine and the Al, Na, K, Ca, P-content to enrich in remaining inclusions in the olivine. This crystallization did not occur in the sample with only bentonite addition, or in the sample with unreactive olivine at these temperatures. However, with further addition of fine quartzite, the slag of the sample with coarse olivine also crystallized. In the samples reduced at 1000–1100°C, magnesium gradients could be detected in the slag phase around coarse olivine particles until entering the interaction volume of an interfering particle at around ~600 μm, or occasionally at distances of more than 1 mm. For the coarse olivine the main rise in magnesium occurs at 1200°C when the olivine particle cores begin to dissolve. The dissolution of all magnesium of the 2.5% olivine addition during oxidation lead to 6.5% Mg in the crystallized slag phase. The increase in melting point resulting from this compared to fayalite with no magnesium is ~50°C, according to thermodynamic calculations.

著者

• Bjorkman Bo

  Division Of Extractive Metallurgy Lulea University Of Technology

• Semberg Par

  Division Of Extractive Metallurgy Lulea University Of Technology

• Björkman Bo

  Division of Sustainable Process Engineering, Luleå University of Technology

• Andersson Charlotte

  LKAB

関連論文

• BOS Vessel Vibration Measurement for Foam Level Detection
• Blast Furnace Pellet Textures during Reduction and Correlation to Strength
• Effect of Reduction Conditions on the Swelling Behaviour of Cement-bonded Briquettes
• Numerical Analysis on the Similarity between Steel Ladles and Hot-water Models Regarding Natural Convection Phenomena
• Effect of Processing Parameters on the Swelling Behaviour of Cement-bonded Briquettes
• Swelling Behaviour of Cement-bonded Briquettes-proposed Model
• Physical and Mathematical Modelling of Thermal Stratification Phenomena in Steel Ladles
• Interactions between Iron Oxides and the Additives Quartzite, Calcite and Olivine in Magnetite based Pellets
• BOS Vessel Vibration Measurement for Foam Level Detection
• Interaction between Iron Oxides and Olivine in Magnetite Pellets during Reduction to Wustite at Temperatures of 1000–1300°C

スポンサーリンク