Modeling the Liquid Levels in the Blast Furnace Hearth
スポンサーリンク
概要
- 論文の詳細を見る
The drainage of a blast furnace hearth is analyzed on the basis of measurements of the instantaneous mass flow rates of tapped iron and slag, obtained from radar level measurements in the iron ladles and a pressure signal from the slag granulation drum. The measurements are used in a model estimating the levels of liquids in the blast furnace hearth, where correction terms have been introduced to prevent the level estimates from excessive drift. When applying the model on data from two Finnish blast furnaces, it was found that the estimated iron level exhibited strong correlation with the electromotive force (emf ) measured between two electrodes at the furnace shell. The results of the model are in general agreement with results reported by other investigators. The performance of the model is illustrated by some examples, and aprocedure for considering the case of a floating dead man is proposed.
- 社団法人 日本鉄鋼協会の論文
- 2001-10-15
著者
-
Saxen Henrik
Heat Engineering Laboratory Abo Akademi University
-
Saxen Henrik
Heat Engineering Laboratory Faculty Of Chemical Engineering Åbo Akademi University
-
Braennbacka J
Abo Akademi Univ. Abo Fin
-
Brannbacka Johnny
Heat Engineering Laboratory Abo Akademi University
関連論文
- Identification of the Combustion Degree of Oil in the Blast Furnace Tuyeres
- Application of Nonlinear Time Series Analysis to the Prediction of Silicon Content of Pig Iron
- Assessment of the State of the Blast Furnace High Temperature Region by Tuyere Core Drilling
- Mathematical Optimization of Ironmaking with Biomass as Auxiliary Reductant in the Blast Furnace
- Nonlinear Prediction of the Hot Metal Silicon Content in the Blast Furnace
- Indicators of the Internal State of the Blast Furnace Hearth
- Model of the State of the Blast Furnace Hearth
- Neural Network Model of Burden Layer Formation Dynamics in the Blast Furnace
- Model Analysis of the Operation of the Blast Furnace Hearth with a Sitting and Floating Dead Man
- Prediction of a Blast Furnace Burden Distribution Variable
- Modeling the Liquid Levels in the Blast Furnace Hearth
- On-line Estimation of the Ore-to-coke Ratio in the Blast Furnace Center